Abstract:Iron-containing (10 w/w%) MCM-41 catalysts were prepared and tested for catalytic wet peroxide oxidation (CWPO) of phenol aqueous solutions in a fixed bed reactor. First, Fe2O3/MCM-41 catalysts were prepared by incipient wetness impregnation and characterized by using X-ray diffraction (XRD), N-2 adsorption-desorption and X-ray photoelectron spectra (XPS), respectively. Second, the effect of temperature, catalyst bed height and feed flow rate on phenol mineralization, hydrogen peroxide and total organic carbon (TOC) conversions were studied to determine the optimum condition. Moreover, Fe leaching concentration was detected to study the stability of the Fe2O3/MCM-41 catalyst. Finally, the evolution of intermediates was monitored to investigate the probable reaction mechanism of phenol oxidation over Fe2O3/MCM-41 catalyst in the fixed bed reactor. The experimental results showed that the conversion of TOC reached 72.5% and few Fe (0.01 mg/L) was detected under optimum condition (namely, feed flow rate of 2.0 ml/min, temperature of 80 degrees C, catalyst bed height of 4 cm). The probable multistep reaction route for oxidative destruction of phenol over Fe2O3/MCM-41 catalyst in a fixed bed reactor is based on hydroxyl radical reacting with phenol, resulted in aromatics such as catechol and hydroquinone, and p-benzoquinone, followed by evolution to carboxylic acids and finally completing oxidation to carbon dioxide and water. Few intermediate products were detected in the treated effluent when the catalyst bed height was higher than 2 cm. (C) 2016 Elsevier B.V. All rights reserved.

Study of phenol removal using fluidized-bed Fenton process

Phenolic Wastewater Treatment by Fenton Reagent in Gas-Liquid Fluidized Bed Reactor

Phenolic wastewater treatment by oxidation-adsorption combination process

Oxidation Treatment of Phenol and Formaldehyde Wastewater by Fenton Reagent

Experimental Research on Phenolic Simulated Wastewater Treatment by Oxidation Process

Study on Fenton reagent-modified fly ash for treatment of phenol wastewater

Removal of Major Organic Pollutants in Coking Wastewater by Fenton Oxidation Pre-Treatment

Fe3O4 nanoparticles as an efficient heterogeneous Fenton catalyst for phenol removal at relatively wide pH values.

Study on Treatment Efficiency of Phenolic Compounds by Fenton Reagent

Microwave Irradiation Treatment Of Phenol In Water Based On Fenton Process

Catalytic Wet Peroxide Oxidation of Phenol over Fe2o3/Mcm-41 in A Fixed Bed Reactor

Degradation of Phenol by Heterogeneous Phase Fenton Reagent Oxidation Process with Fe2+/Activated Carbon Catalyst

Treatment of Phenol WasteWater with Modified Coal Fly Ash-Fenton Reagent

Preparation of Heterogeneous Fenton Catalyst Γ-Cu-ce-al2o3 and the Evaluation on Degradation of Phenol

The effect of use of Ni/Fe and mZVI on phenol removal with the heterogenous fenton process and in-situ generation of H2O2

Enhanced Removal Ability of Phenol from Aqueous Solution Using Coal-Based Carbon Membrane Coupled with Electrochemical Oxidation Process

A New Insight into Fenton and Fenton-like Processes for Water Treatment.

Microwave-Induced Catalytic Oxidation Process for Treatment of Phenol in Water with Fe2O3/Al2O3 Catalyst

Treatment of Coking Wastewater by an Advanced Fenton Oxidation Process Using Iron Powder and Hydrogen Peroxide

Enhanced removal of phenol from biorefinery wastewater treatment using enzymatic and Fenton process

Treatment of Phenols-containing wastewater by iron chips-Fenton process