Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Electrical characteristics of multi-gate P-channel FinFETs with VT implanting energies under temperature stress

Mechanical Strain Altered Gate and Substrate Currents in N and P-Channel MOSFETs

Electrical characteristic of thin film FET under temperature and Gpa order stress

Strain Optimization in Silicon P-Type Double-Gate MOSFET at 7nm Channel Length

Impact of Hot Carrier Degradation and Bias Temperature Instability on GHz Cycle-to-Cycle Variation in Ultra-Scaled FinFETs

A comparative study on electrothermal characteristics of nanoscale multiple gate MOSFETs.

Temperature Dependences of Threshold Voltage and Drain-Induced Barrier Lowering in 60nm Gate Length MOS Transistors

Theoretical Study of Self-Heating-Induced Thermal Stress Effects on Quantum Transport in P-Type Ultrathin Body-FinFET by Multiphysics Simulation

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Multiphysics Simulation of Self-Heating-Induced Thermal Stress Effects on Quantum Transport in Gate-All-Around Nanosheet Field Effect Transistors

Multiphysics Simulation Study of Thermal Stress Effects in Nanoscale FinFETs Heterogeneously Integrated with GaN High-Power Device on Silicon Substrate

Tunneling Field-Effect Transistor: Effect of Strain and Temperature on Tunneling Current

Evaluation on Temperature-Dependent Transient VT Instability in p-GaN Gate HEMTs under Negative Gate Stress by Fast Sweeping Characterization

Localized Thermal Effect Enhanced NBTI in Multifin Pfinfets under Low Drain Bias

Electrothermal Effects on Hot Carrier Injection in N-Type Soi Finfet under Circuit-Speed Bias

Investigation of thermal stress effects on subthreshold conduction in nanoscale p-FinFET from Multiphysics perspective

Study on The Degradations Produced by Different P-base Diffusion Temperatures on SGT MOSFET With Approximate Threshold Voltage

Threshold voltage instability of SiC MOSFETs under very‐high temperature and wide gate bias

Influence of well doping on the performance of UTBB MOSFETs

Signature of electrothermal transport in 18nm vertical junctionless gate-all-around nanowire field effect transistors

Positive Bias Temperature Instabilities in Vertical Gate-all-around Poly-Si Nanowire Field-effect Transistors