Abstract:A hybrid process of controlled nitrification by membrane aerated biofilm (MAB), partial denitrification (PD) by activated sludge, and anaerobic ammonia oxidation (ANAMMOX) by granular sludge was proposed for synthetic low strength and COD/N wastewater treatment to address the challenges of stable nitritation and limited carbon source for nitrogen removal in this study. Batch tests with different aeration pressures showed that MAB achieved ammonia-nitrogen removal of around 57% and nearly full nitrification under aeration pressure of 6 kPa and reaction time of 9 h, resulting in appropriate conditions for subsequent PD and ANAMMOX. Batch tests with different COD/N ratios revealed that PD activated sludge achieved an average 88% conversion from nitrate to nitrite and a nitrite-nitrogen production rate of 1.24 mg/L/min under the optimal initial COD/N of 3.5 and MLVSS of 1.3 g/L. Batch tests on ANAMMOX showed a nitrite-nitrogen consumption rate of 0.13 mg/L/min under granular sludge MLVSS of 13 g/L. Furthermore, batch tests mixing PD activated sludge and ANAMMOX granular sludge demonstrated the optimal seeding sludge weight ratio of 1:10 for simultaneous nitrate and ammonia removal. Finally, the hybrid process of controlled nitrification by MAB, PD by activated sludge, and ANAMMOX by granular sludge was established to treat synthetic low strength and COD/N wastewater (COD of 175 mg/L, ammonia-nitrogen of 100 mg/L). After 10 cycles of operation with a reaction time of 9 h, the effluent ammonia-nitrogen decreased to below 10 mg/L, nitrate and nitrite nitrogen were below 3 mg/L, and COD was below 50 mg/L, achieving simultaneous carbon and nitrogen removal capacity of 0.36 gCOD/L/d and 0.23 gN/L/d, respectively.

Use of aerobic granules for treating synthetic high-strength ammonium wastewaters.

A Case for Aerobic Sludge Granulation: from Pilot to Full Scale

Adsorption of Ammonium by Aerobic Granules under High Ammonium Levels

Enhanced Nitrogen Removal from Ammonium-Rich Wastewater Containing High Organic Contents by Coupling with Novel High-Rate ANAMMOX Granules Addition

Aerobic granules formation and simultaneous nitrogen and phosphorus removal treating high strength ammonia wastewater in sequencing batch reactor

Aerobic granular sludge for high-strength ammonium wastewater treatment: Effect of COD/N ratios, long-term stability and nitrogen removal pathways

Partial Nitrification Adjusted by Hydroxylamine in Aerobic Granules under High DO and Ambient Temperature and Subsequent Anammox for Low C/N Wastewater Treatment

Partial nitrification of wastewaters with high NaCl concentrations by aerobic granules in continuous-flow reactor

Performance of ANAMMOX-EGSB Reactor

Treatment of wastewater with a high NH~+_4-N concentration by aerobic granular sludge

Granulation and Characteristics of Extracellular Polymers of Anammox Sludge in High-Load EGSB Reactor

Performance of A Nitrifying Airlift Reactor Using Granular Sludge

Formation of Aerobic Granular in Pilot-scale SBR for Real Wastewater Treatment

Deep Purification of Low-Strength Ammonium-Containing Wastewater with ANRE Process

COD removal and nitrification of low-strength domestic wastewater in aerobic granular sludge sequencing batch reactors

Aerobic Granular Sludge Treating Low-Strength Municipal Wastewater: Efficient Carbon, Nitrogen and Phosphorus Removal with Hydrolysis-Acidification Pretreatment.

AEROBIC SLUDGE GRANULATION FOR PARTIAL NITRIFICATION OF AMMONIA-RICH INORGANIC WASTEWATER

Low strength and COD/N wastewater treatment via controlled nitrification by membrane aerated biofilm, partial denitrification by activated sludge, and anaerobic ammonia oxidation by granular sludge

Removal of nitrogen from wastewaters by anaerobic ammonium oxidation (ANAMMOX) using granules in upflow reactors

Coupling of endogenous/exogenous nitrification and denitrification in an aerobic granular sequencing batch reactor