Abstract:This paper presents a monolithically integrated aptasensor composed of a piezoresistive microcantilever array and an on-chip signal processing circuit. Twelve microcantilevers, each of them embedded with a piezoresistor, form three sensors in a Wheatstone bridge configuration. The on-chip signal processing circuit consists of a multiplexer, a chopper instrumentation amplifier, a low-pass filter, a sigma-delta analog-to-digital converter, and a serial peripheral interface. Both the microcantilever array and the on-chip signal processing circuit were fabricated on the single-crystalline silicon device layer of a silicon-on-insulator (SOI) wafer with partially depleted (PD) CMOS technology followed by three micromachining processes. The integrated microcantilever sensor makes full use of the high gauge factor of single-crystalline silicon to achieve low parasitic, latch-up, and leakage current in the PD-SOI CMOS. A measured deflection sensitivity of 0.98 × 10 − 6 nm −1 and an output voltage fluctuation of less than 1 μV were obtained for the integrated microcantilever. A maximum gain of 134.97 and an input offset current of only 0.623 nA were acquired for the on-chip signal processing circuit. By functionalizing the measurement microcantilevers with a biotin-avidin system method, human IgG, abrin, and staphylococcus enterotoxin B (SEB) were detected at a limit of detection (LOD) of 48 pg/mL. Moreover, multichannel detection of the three integrated microcantilever aptasensors was also verified by detecting SEB. All these experimental results indicate that the design and process of monolithically integrated microcantilevers can meet the requirements of high-sensitivity detection of biomolecules.

Moore'S Law In Homeland Defense: An Integrated Sensor Platform Based On Silicon Microcantilevers

Molecular Recognition of Chem/Biowarfare Agents Using Micromechanical Sensors

Molecular recognition of biowarfare agents using micromechanical sensors.

Chemical Specificity in Nanomechanical Sensors

Microcantilever Biosensors for Chemicals and Bioorganisms

MEMS Sensors and Wireless Telemetry for Distributed Systems

Multiple-input microcantilever sensors

A prototype portable instrument employing micro-preconcentrator and FBAR sensor for the detection of chemical warfare agents

Controllable synthesis of conjugated microporous polymer films for ultrasensitive detection of chemical warfare agents

Design and analysis of novel MEMS cantilever biosensor with special focus on SCR for tuberculosis detection

Advanced Sensor Technology Based on Oxide Thin Film—MEMS Integration

MULTIPLE-INPUT MICROCANTILEVER SENSOR WITH CAPACITIVE READOUT

An Integrated Portable Multiplex Microchip Device for Fingerprinting Chemical Warfare Agents

Microcantilever-based platforms as biosensing tools

Quad-cantilever microsensors with a low-cost single-sided micro-machining technique for trace chemical vapor detection

A Monolithically Integrated Microcantilever Biosensor Based on Partially Depleted SOI CMOS Technology

Investigating a Detection Method for Viruses and Pathogens Using a Dual-Microcantilever Sensor

A Compact, Low-Power Cantilever-Based Sensor Array for Chemical Detection

Sensor Security: Current Progress, Research Challenges, and Future Roadmap

Remote Sensing with Commutable Monolithic Laser and Detector

Design and Modification of MEMS Based Micro Cantilever