Abstract:Tire Pressure Monitoring System (TPMS) has become an important automotive electronic safety device with extensive application for vehicles,but traditional TPMS is typically internal device. The sensor unit is placed inside of tires,which is hard to maintain and install. The metal wires nested inside of tire have strong shielding effect for sensor and wireless transmission,and the signal is largely attenuated because of that. In order to guarantee that the signal can reach the receiver placed on the driving panel,the transmission power must be increased thus seriously decrease the battery lifetime. To solve all these technical difficulties,a new type of external TPMS sensing device with direct pressure measurement has been developed. The key component of new TPMS is a MCU from Infineon SP30 with build-in MEMS pressure sensor. The tire pressure can be measured directly from valve stem connection and pressure data is transmitted wirelessly to the monitor on the driving panel. It avoids the signal shielding effect,extends the battery life and reduces maintenance cost. The specific circuit design,software and protocol for communication have been given in this paper. The system is demonstrated with identified characteristics such as very stable wireless transmission,good performance for anti-interference,accurate recognition for tire position,fast response time for pressure change,easy installation and maintenance,and very flexible for tire configuration,etc. The new TPMS device has big prospect for real application.

A novel ESD device for Whole-Chip ESD protection network of TPMS mixed signal SoC

Mixed-Signal Soc Design and Low Power Research for Tire Pressure Monitoring Systems

Lightweight Secure Communication Protocols for In-Vehicle Sensor Networks

A Novel and Powerful TCAD Methodology to Evaluate Performance of ESD Protection Devices

External Digital Tire Pressure Monitoring System Based on MEMS Pressure Sensor

On Chip Electrostatic Discharge Protection for MEMS Gas Sensor System

Implementation Of Temperature Dependent Contact Resistance Model For The Analysis Of Deep Submicron Devices Under Esd

A Low Power MCU Design for Battery-Less TPMS SoC

Key Module Design Of A Battery-Less Tpms On Chip

Whole-Chip ESD Protection Design for Deep Submicron Mix-Signal CMOS VLSI

An Intelligent TPMS Solution Based on MEMS Sensor

A 125 kHz Power Recovery Circuit Design for Battery-less TPMS SoC

FOD Based ESD Protection Devices in Deep Sub-micron Technology

A 125khz Low Frequency Power Recovery Circuit for Battery-Less Tpms Soc

Robustness Evaluation Of Esd Protection Devices In Nems Using A Novel Tcad Methodology

A Tire Pressure Monitoring System Based on Mems Sensor

Wireless power transfer and a Dual-Slope ADC design for Battery-less TPMS

Design of the RF Technology Tire Pressure Monitoring System

Design Analysis of a Novel Low Triggering Voltage Dual Direction SCR ESD Device in 0. 18μm Mixed Mode RFCMOS Technology

System Efficient ESD Design of IO ESD Protection

Study of Novel Passive Tire Pressure Monitoring System Based on Integrated Sensor