Abstract:Bulk lifetime studies of crystalline silicon wafers, e.g. with the aim of studying the light-induced degradation and regeneration behavior, require low-temperature surface passivation schemes that do not alter the silicon bulk properties, e.g. through hydrogenation. Aluminum oxide (Al2O3) can provide an excellent and stable surface passivation, however, in order to achieve the best possible surface passivation, an annealing step at ∼400°C is typically required, which has been found to alter the bulk properties of some silicon materials. Hence, in this contribution we examine the possibility of passivating the silicon surface using Al2O3 layers that have seen a much lower thermal budget. We demonstrate that we are able to achieve an excellent silicon surface passivation using atomic-layer-deposited Al2O3 with measured effective surface recombination velocities Seff as low as 1.3 cm/s without exceeding a temperature of 250°C. We are able to achieve such excellent low-temperature passivation by applying a post-deposition annealing step at 250°C in combination with the deposition of negative Corona charges on the Al2O3 surface. For samples annealed at only 220°C, we still reach very low Seff values of 2 cm/s after deposition of negative Corona charges. We demonstrate that the Corona-charged low-temperature Al2O3 passivation shows only a slight degradation from an Seff of 1.6 cm/s to an Seff of 5 cm/s after 218 days of storage. Even without any post-deposition anneal and only negative Corona charges deposited, we achieve stable Seff values of 15 cm/s. As an alternative to Corona charging, a short exposure to intense UV light (λ = 395 nm) also significantly improves the surface passivation quality of low-temperature-annealed Al2O3-passivated silicon samples. However, the best surface passivation for the latter method is limited to an Seff value of 6.6 cm/s, which is still quite reasonable for bulk lifetime studies.

Characterization of Al2O3 surface passivation of silicon solar cells

Spray coated aluminum oxide thin film for P-type crystalline silicon surface passivation

Aluminum Oxide Deposited by Pulsed-DC Reactive Sputtering for Crystalline Silicon Surface Passivation

Oxide-nitride nanolayer stacks for enhanced passivation of p-type surfaces in silicon solar cells

Light-soaking Enhanced Passivation of Al2O3 on Crystalline Silicon Surface

Role of Annealing Conditions on Surface Passivation Properties of ALD Al2O3 Films

Enhanced Si Passivation and PERC Solar Cell Efficiency by Atomic Layer Deposited Aluminum Oxide with Two-step Post Annealing

Highly effective passivation of crystalline silicon surfaces achieved through transparent conductive Al-doped ZnO layers

Dual Function of Antireflectance and Surface Passivation of Atomic-Layer-Deposited $\hbox{al}_{2}\hbox{o}_{3}$ Films

Mechanisms of Silicon Surface Passivation by Negatively Charged Hafnium Oxide Thin Films

RF Magnetron Sputtering Aluminum Oxide Film for Surface Passivation on Crystalline Silicon Wafers

Efficiency improvement of PERC solar cell using an aluminum oxide passivation layer prepared via spatial atomic layer deposition and post-annealing

Dual functions of anti-reflectance and surface passivation of the atomic layer deposited Al2O3 films on crystalline silicon substrates

Simulation of a Charged Al2O3 Film as an Assisting Passivation Layer for a-Si Passivated Contact P-Type Silicon Solar Cells

Low-temperature silicon surface passivation for bulk lifetime studies based on Corona-charged Al2O3

Improved Silicon Surface Passivation by ALD Al2O3/SiO2 Multilayers with In‐Situ Plasma Treatments

Improving Silicon Surface Passivation with a Silicon Oxide Layer Grown via Ozonated Deionized Water

A review of Al2O3 as surface passivation material with relevant process technologies on c-Si solar cell

Study of Gamma-Ray Radiation Effects on the Passivation Properties of Atomic Layer Deposited Al2O3 on Silicon Using Deep-Level Transient Spectroscopy

Novel silicon surface passivation by porous silicon combined with an ultrathin Al2O3 film

Ultrathin Aluminum Oxide Films Induced by Rapid Thermal Annealing for Effective Silicon Surface Passivation