Abstract:Results are presented for modelling of the evaporation and magnetron sputter deposition of Zn(x)O(y) onto an O-terminated ZnO (0001¯) wurtzite surface. Growth was simulated through a combination of molecular dynamics (MD) and an on-the-fly kinetic Monte Carlo (otf-KMC) method, which finds diffusion pathways and barriers without prior knowledge of transitions. We examine the effects of varying experimental parameters, such as substrate bias, distribution of the deposition species and annealing temperature. It was found when comparing evaporation and sputtering growth that the latter process results in a denser and more crystalline structure, due to the higher deposition energy of the arriving species. The evaporation growth also exhibits more stacking faults than the sputtered growth. Post-annealing at 770 K did not allow complete recrystallization, resulting in films which still had stacking faults where monolayers formed in the zinc blende phase, whereas annealing at 920 K enabled the complete recrystallization of some films to the wurtzite structure. At the latter temperature atoms could also sometimes be locked in the zinc blende phase after annealing. When full recrystallization did not take place, both wurtzite and zinc blende phases were seen in the same layer, resulting in a phase boundary. Investigation of the various distributions of deposition species showed that, during evaporation, the best quality film resulted from a stoichiometric distribution where only ZnO clusters were deposited. During sputtering, however, the best quality film resulted from a slightly O rich distribution. Two stoichiometric distributions, one involving mainly ZnO clusters and the other involving mainly single species, showed that the distribution of deposition species makes a huge impact on the grown film. The deposition of predominantly single species causes many more O atoms at the surface to be sputtered or reflected, resulting in an O deficiency of up to 18% in the deposited film and therefore resulting in more stacking faults and phase boundaries. The methods used allow analysis of key mechanisms that occur during the growth process and give hints as to the optimum conditions under which complete crystalline layers can form.

Structural Evolvement of ZnO Nanoporous Films Fabricated Using Prolonged Electrodeposition under Pulsed Voltages

The growth of nanoscale ZnO films by pulsed-spray evaporation chemical vapor deposition and their structural, electric and optical properties

Effect of Nucleation and Growth Kinetics on the Electrical and Optical Properties of Undoped ZnO Films

Effect of Electrodeposition Time on Microstructure, Wettability and Optical Properties of ZnO Nanorod Arrays

Effects of Electrodeposition Electrolyte Concentration on Microstructure, Optical Properties and Wettability of ZnO Nanorods

Structural and Optical Characterizations of ZnO Films Grown by Reactive Electron Beam Evaporation

Growth Mechanism of ZnO Nanostructures in Wet-Oxidation Process

Growth Mechanism And Properties Of Zno Nanorods Synthesized By Plasma-Enhanced Chemical Vapor Deposition

Modelling the growth of ZnO thin films by PVD methods and the effects of post-annealing

STRUCTURAL AND OPTICAL STUDIES OF ZnO FILMS GROWN AT LOW TEMPERATURE

Growth and Photocatalytic Properties of One-Dimensional Zno Nanostructures Prepared by Thermal Evaporation

Electrochemical Self-Assembly Of Zno Nanoporous Structures

Growth of Zn thin films based on electric field by thermal evaporation method and effect of oxidation time on physical properties of ZnO nanorods

Development of ZnO Nanostructured Films via Sodium Chloride Solution and Investigation of Its Growth Mechanism and Optical Properties

Fabrication of Transparent Zinc Oxide Film with Electrochemical Deposition

Electrochemical Growth of Nanopillar Zinc Oxide Films by Applying a Low Concentration of Zinc Nitrate Precursor

Electrochemical Growth and Control of ZnO Dendritic Structures

Catalyst-free Growth and Tailoring Morphology of Zinc Oxide Nanostructures by Plasma-Enhanced Deposition at Low Temperature

Effects Of Electrodeposition Conditions On The Microstructures Of Zno Thin Films

Synthesis and Optical Property Study on ZnO Nanostructures Via Vapor Phase Growth

Fabrication and Growth Mechanism of ZnO Nanorods by Electrochemical Method