Abstract:In the present work, the gasification performances of two pairs of raw and torrefied biomasses, including raw forest residue and torrefied forest residue, and raw spruce and torrefied spruce in a high-temperature entrained-flow reactor, are numerically examined and compared to each other using a Eulerian-Lagrangian CFD model developed based on OpenFOAM. Moreover, the sensitivities of three important operating parameters (excess air ratio, steam/carbon molar ratio, and biomass particle diameter), which vary in the range of practical significance, are also tested. The calculated results are analyzed both qualitatively and quantitatively by five indicators: isothermal profiles, char consumption rate, gas compositions, species yield, and carbon conversion along the reactor length. The obtained results show that torrefied biomass can increase the maximum temperature in the reactor as compared to its raw parent fuel. During gasification, CO, H-2, and CO2 are the major species in the product gas and CH4 accounts for only a very small fraction of the syngas at such a high operating temperature of 1400 degrees C. As expected, the higher the excess air ratio, the lower the H-2 yield and higher CO2 production and carbon conversion; a rise in the steam/carbon molar ratio promotes the H-2 yield but reduces the CO production; and both the H-2 and CO yields and carbon conversion decrease with increasing particle diameter. In addition, three reaction zones can be recognized from the carbon conversion along the reactor length, and such information is useful for optimal reactor design. In all cases, torrefaction consistently reduces both the H-2 production and carbon conversion as compared to its raw biomass under the same operating conditions, which suggests that torrefied biomass requires a bigger length entrained-flow gasifier or longer particle residence time to achieve the same level of conversion as that for its raw biomass.

Study of the Gasification Performance of a Downdraft Type Biomass Gasifier

FLOW FIELD SIMULATIONS AND EXPERIMENT OF IMPROVED AIR SUPPLY UNITS FOR UPDRAFT-BIOMASS GASIFIER

Research of Household-type Downdraft Biomass Gasifier Properties

Gasification Characteristics Of Biomass In Different Ambiences

Comparison of Gasification Performances Between Raw and Torrefied Biomasses in an Air-Blown Fluidized-Bed Gasifier

Co-gasification of Acid Hydrolysis Residues and Sewage Sludge in a Downdraft Fixed Gasifier with CaO As an In-Bed Additive

The Development of New-type Downdraft Biomass Gasifier

Effect of Air Equivalence Ratio on the Characteristics of Biomass Partial Gasification for Syngas and Biochar Co-Production in the Fluidized Bed

Pilot-scale study on downdraft gasification of municipal solid waste with mass and energy balance analysis

System characteristics and performance evaluation of a trailer-scale downdraft gasifier with different feedstock

Influence of Torrefaction on Biomass Gasification Performance in A High-Temperature Entrained-Flow Reactor

Hydrogen-rich gas production from biomass air and oxygen/steam gasification in a downdraft gasifier

Research of Characteristics Biomass Staged-Gasification for Hydrogen-Rich Syngas

Steady and transient state behavior of a gasification process under fixed-bed downdraft configuration

Tar character and cleaning of biomass gasification gas

Numerical simulation analysis of biomass gasification and rich-H2 production process in a downdraft gasifier

Experimental Study on Autothermal Cyclone Air Gasification of Biomass

Analysis of Operational Problems and Improvement Measures for Biomass-Circulating Fluidized Bed Gasifiers

Study Of Biomass Gasification And Combustion

EXPERIMENTAL STUDY ON GASIFICATION IN DUAL FLUIDIZED BEDS

Biomass-oxygen Gasification in a High-Temperature Entrained-Flow Gasifier.