Abstract:This research focused on the reaction features and kinetics of tar catalytic conversion by char based on the generation and evolution of gas products. To probe the roles of heat and catalysis in tar conversion, a micro fluidized bed reaction analyzer (MFBRA) was used to assess tar thermal cracking (TC) and catalytic cracking (CC) by char at 1073, 1123, 1173, and 1223 K. The tar cracking behavior of the individual gas components (H 2 , CO, CO 2 , and CH 4 ), generation rates, and reaction kinetics were thoroughly investigated. The results show that TC and CC included a fast (Stage-1) and slow (Stage-2) conversion stage, in which Stage-1 contributed more than 80% of the total conversion. Compared to TC, tar CC required a longer reaction time but obtained higher conversions to individual gas components and the total gas products. The final conversion ratios ( X CC/TC ) of H 2 , CO, CO 2 , and CH 4 were kept above 1 at the tested temperature. The char catalytic action was very remarkable, especially at low temperatures. In tar CC, the generation rate of individual gas components slowly declined after quickly reaching the peak, forming a relatively stable zone. The volume reaction model (VRM) well described the tar conversion behavior with and without char. Compared to TC, char lowered the activation energy ( Ea ) of gas generation. For individual gas components (H 2 , CO, CO 2 , CH 4 ) and the total gas products, the corresponding reduction degree of Ea was 25.56%, 24.18%, 22.14%, 4.75%, and 21.71%, respectively, further displaying the promoting impact of char. The evaluated generation features and kinetics of individual components in the gas products will benefit the in-situ tar removal in the biomass gasification process.

Experimental Study on Autothermal Cyclone Air Gasification of Biomass

Effect of Air Equivalence Ratio on the Characteristics of Biomass Partial Gasification for Syngas and Biochar Co-Production in the Fluidized Bed

Research of Characteristics Biomass Staged-Gasification for Hydrogen-Rich Syngas

Experimental Investigation Of Tar Reduction Properties By Coupling Oxidative Pyrolysis And Partial Oxidation In A Continuous Reactor For Biomass Gasification

Experimental research on air staged cyclone gasification of wood powder

Characteristics of Rice Husk Gasification in Cyclone Pyrolysis-Suspended Combustion System

Experiments and Numerical Simulation of Sawdust Gasification in an Air Cyclone Gasifier

Experimental Research on Air Staged Cyclone Gasification of Rice Husk

Experimental Research on Fuel Staging Cyclone Gasification of Wood Powder

Investigation into the Operation of an Autothermal Two-Section Subbituminous Coal Fluidized Bed Gasifier

High Temperature Gasification of High Heating-Rate Chars Using a Flat-Flame Reactor

Experimental Study on Cyclone Air Gasification of Wood Powder

Experimental Research In Biomass Pyrolysis And Interparticle Heat Transfer

Experimental Study on Properties of Syngas, Tar, and Biochar Derived from Different Gasification Methods

Two-Stage Dry Reforming Process for Biomass Gasification: Product Characteristics and Energy Analysis

Experimental Study on Coal Partial Gasification Coproducing Char, Tar, and Gas

Experimental Study on Sawdust Air Gasification in an Entrained-Flow Reactor

Generation features and kinetics of gas products in bio-tar catalytic cracking by char for biomass gasification

Assessment of low‐rank coal and biomass co‐pyrolysis system coupled with gasification

Experimental study on supercritical carbon dioxide gasification of biomass

Structural and Gasification Kinetic Studies on Co-pyrolysis Chars of Coal and Biomass