Abstract:The effects of substrate temperature and O-2 flux on structural, electrical, and optical properties of the films prepared by RF reactive magnetron sputtering with SnF2-Sn target have been investigated by X-ray diffraction (XRD), Hall effect measurements, optical transmission spectra, and photoluminescence (PL) spectra. It is found that F-doped SnO films are produced and exhibit amorphous structure at lower O-2 fluxes for substrate temperature of RT-300 degrees C, and window of O2 flux for depositing the films is reduced as substrate temperature increases. F-doped SnO2 (FTO) films are formed at higher O-2 fluxes, and they exhibit amorphous state at substrate temperature of RT but crystalline state at substrate temperature of 150 and 300 degrees C. Furthermore, increasing O-2 flux or substrate temperature can promote crystallinity and affect growth orientation for crystalline FTO films. Highly conductive FTO films can be obtained only at suitable O-2 fluxes and higher substrate temperatures (150 and 300 degrees C), at which the films keep crystalline SnO2 structure along with high amount of oxygen vacancy (V-O). Increasing substrate temperature from 150 to 300 degrees C, the resistivity of FTO films cannot be further decreased due to the out-diffusion of F although the film crystallinity improves. Compared with F-doped SnO films, the average transmittance in visible light range and band gap (E-g) of FTO films obviously increase. The FTO films show similar shaped PL spectra that can be attributed to substitutional fluorine (F-O) and V-O defects in the films, and PL emission intensity increases with increasing O-2 flux or substrate temperature due to the improvement of film crystallinity. It is observed that the PL emission characteristics (shape and intensity) of F-doped SnO film are obviously different from FTO films and they have great changes as substrate temperature from RT to 150 degrees C, but corresponding mechanisms need to further clarify. (C) 2017 Elsevier B.V. All rights reserved.

Effects of substrate temperatures on the structure andproperties of hafnium dioxide films

Influence of Deposition Temperature on the Structure and Optical Properties of HfO2 Thin Films

Microstructure Optimization and Optical and Interfacial Properties Modulation of Sputtering-Derived Hfo2 Thin Films by Tio2 Incorporation

Annealing Temperature Dependent Microstructure and Optical Properties of HfxTi1-xO2 Thin Films

Thermal Transport Mechanism of Amorphous HfO 2 : A Molecular Dynamics Based Study

Modulation of the structural and optical properties of sputtering-derived HfO2 films by deposition power

The Effects of Oxygen Partial Pressure and Substrate Temperature on the Structural and Optical Properties of Zno Films

Microstructure, Optical, Electrical Properties, and Leakage Current Transport Mechanism of Sol–gel-Processed High-K HfO2 Gate Dielectrics

Thermal and Voltage Instabilities of Hafnium Oxide Films Prepared by Sputtering Technique

Effect of Deposition Temperature on the Surface, Structural, and Mechanical Properties of HfO2 Using Chemical Vapor Deposition (CVD)

Crystallinity Effect on Electrical Properties of PEALD–HfO2 Thin Films Prepared by Different Substrate Temperatures

Influence of the deposition method on the laser induced damage threshold of HfO2 thin films

Investigation of HfO2 Thin Films on Si by X-ray Photoelectron Spectroscopy, Rutherford Backscattering, Grazing Incidence X-ray Diffraction and Variable Angle Spectroscopic Ellipsometry

Effect of Oxygen Flow on the Optical Properties of Hafnium Oxide Thin Films by Dual-Ion Beam Sputtering Deposition

Hysteresis-free HfO2 Film Grown by Atomic Layer Deposition at Low Temperature

Effect of film thickness on phase structure of epitaxial non-doped hafnium oxide films

Effects of substrate temperature on the efficiency of hydrogen incorporation on the properties of Al-doped ZnO films

Effects of substrate temperature on structure, thermal stability and mechanical property of a Zr-based metallic glass thin film

Sputtering deposition of transparent conductive F-doped SnO2 (FTO) thin films in hydrogen-containing atmosphere

Structural, Electrical, and Optical Properties of F-doped SnO or SnO2 Films Prepared by RF Reactive Magnetron Sputtering at Different Substrate Temperatures and O2 Fluxes

Effects of substrate temperature and oxygen pressure on the magnetic properties and structures of CoFe2O4 thin films prepared by pulsed-laser deposition