Abstract:High efficiency thin-film silicon (Si) solar cells were prepared on flexible substrates by the plasma-enhanced chemical vapor deposition method. To improve their performance, the microstructural, electrical, and optical properties of the core component layers including the metal rear reflectors, p- and n-type doped layers, and intrinsic absorber layers were controlled sophistically. To enable the use of flexible substrates with low heat resistance as well as to enhance light-scattering properties, nanotextured rear reflectors with a Ag/Al:Si bilayer structure were developed by dc magnetron sputtering at a low substrate temperature of below 150 degrees C. Highly crystalline n-doped seed layers (which effectively eliminate a defect-dense amorphous region formed in the initial growth stage of intrinsic nanocrystalline silicon (nc-Si:H) absorber layers) and p-type wide-bandgap nanocrystalline silicon carbide (nc-SiC:H) window layers (which reduce the parasitic absorption loss in the short wavelength region and increase the open circuit voltage (Voc)) were successfully applied to enhance the performance characteristics of the solar cells. Through the combination of the developed core component layers, high conversion efficiencies of 8.84% (V-oc = 0.53 V, J(sc) = 25.28 mA/cm(2), and fill factor (FF) = 0.66, where J(sc) is the short circuit current) and 7.48% (V-oc = 0.50 V, J(sc) = 21.07 mA/cm(2), and FF = 0.71) were obtained for nc-Si:H solar cells fabricated on stainless steel (SUS) and polyimide substrates, respectively, at a low substrate temperature of below 150 degrees C. Flexible a-Si:H/nc-Si:H double-junction solar cells fabricated on SUS substrates showed a high conversion efficiency of 11.46% (V-oc = 1.38 V, J(sc) = 11.53 mA/cm(2), and FF = 032) when the nc-Si:H solar cells developed in this study were applied as a bottom cell.

Formation of Shallow Junctions in Gallium and Phosphorus Compensated Silicon for Cell Performance Improvement

Improved Nanocrystal Formation, Quantum Confinement and Carrier Transport Properties of Doped Si Quantum Dot Superlattices for Third Generation Photovoltaics

Silicon Nanocrystal Conjugated Polymer Hybrid Solar Cells with Improved Performance

Improved performance of GaAs-based micro-solar cell with novel polyimide/SiO 2 /TiAu/SiO 2 structure

Improved Device Performance of Si-based Heterojunction Solar Cells by Using Phosphorus Doped Si Nanocrystals Embedded in SiC Host Matrix

Thin heterojunction a-Si:H photovoltaic cell design with no doped a-Si:H layers

High Performance Nanostructured Silicon-Organic Quasi P-N Junction Solar Cells Via Low-Temperature Deposited Hole and Electron Selective Layer.

Improved Power Conversion Efficiency in Radial Junction Thin Film Solar Cells Based on Amorphous Silicon Germanium Alloys

Optimized Phosphorus Diffusion Process and Performance Improvement of C-Si Solar Cell by Eliminating SiP Precipitates in the Emitter

Simulation and experimental study of a novel bifacial structure of silicon heterojunction solar cell for high efficiency and low cost

PHOTOELECTRIC STRUCTURE DESIGN OF HIGH EFFICIENCY AMORPHOUS SILICON GERMANIUM SOLAR CELL BASED ON LIGHT MANAGEMENT AND BAND GAP PROFILING

Investigation of low band gap silicon alloy thin film solar cell for improving short and long wavelength response

Optimization of p-i-n GaAs/AlGaAs Heterojunction Nanowire Solar Cell for improved Optical and Electrical Properties

Suppression of Surface and Auger Recombination by Formation and Control of Radial Junction in Silicon Microwire Solar Cells

Investigation Of Low-Cost And High Efficiency Ga-Doped Cz-Si Solar Cells

From planar junction to local junction: A new structure design of amorphous/crystalline silicon heterojunction solar cells for high efficiency and low cost

Performance enhancement of a proposed solar cell microstructure based on heavily doped silicon wafers

Silicon heterojunction solar cells with up to 26.81% efficiency achieved by electrically optimized nanocrystalline-silicon hole contact layers

Enhanced efficiency of graphene-silicon Schottky junction solar cell through inverted pyramid arrays texturation

Performance Enhancement of Thin-Film Silicon Solar Cells by Development of Core Component Layers

Monolayer Graphene Film/Silicon Nanowire Array Schottky Junction Solar Cells