Abstract:The magnetoelectric effect (ME) is an important strain mediated-phenomenon in a ferromagnetic-piezoelectric composite for a variety of sensors and signal processing devices. A bias magnetic field, in general, is essential to realize a strong ME coupling in most composites. Magnetic phases with (i) high magnetostriction for strong piezomagnetic coupling and (ii) large anisotropy field that acts as a built-in bias field are preferred so that miniature, ME composite-based devices can operate without the need for an external magnetic field. We are able to realize such a magnetic phase with a composite of (i) barium hexaferrite (BaM) with high magnetocrystalline anisotropy field and (ii) nickel ferrite (NFO) with high magnetostriction. The BNx composites, with (100 - x) wt.% of BaM and x wt.% NFO, for x = 0-100, were prepared. X-ray diffraction analysis shows that the composites did not contain any impurity phases. Scanning electron microscopy images revealed that, with an increase in NFO content, hexagonal BaM grains become prominent, leading to a large anisotropy field. The room temperature saturation magnetization showed a general increase with increasing BaM content in the composites. NFO rich composites with x ≥ 60 were found to have a large magnetostriction value of around -23 ppm, comparable to pure NFO. The anisotropy field HA of the composites, determined from magnetization and ferromagnetic resonance (FMR) measurements, increased with increasing NFO content and reached a maximum of 7.77 kOe for x = 75. The BNx composite was cut into rectangular platelets and bonded with PZT to form the bilayers. ME voltage coefficient (MEVC) measurements at low frequencies and at mechanical resonance showed strong coupling at zero bias for samples with x ≥ 33. This large in-plane HA acted as a built-in field for strong ME effects under zero external bias in the bilayers. The highest zero-bias MEVC of ~22 mV/cm Oe was obtained for BN75-PZT bilayers wherein BN75 also has the highest HA. The Bilayer of BN95-PZT showed a maximum MEVC ~992 mV/cm Oe at electromechanical resonance at 59 kHz. The use of hexaferrite-spinel ferrite composite to achieve strong zero-bias ME coupling in bilayers with PZT is significant for applications related to energy harvesting, sensors, and high frequency devices.

Dynamic Magnetostriction Characteristics of an Fe-Based Nanocrystalline Fecunbsib Alloy

Tunable microwave frequency performance of nanocomposite Co 2MnSi/PZN-PT magnetoelectric coupling structure

E-Field Tuning Microwave Frequency Performance Of Co2fesi/Lead Zinc Niobate-Lead Titanate Magnetoelectric Coupling Composites

Optimized Giant Magnetoimpedance Effect In Amorphous And Nanocrystalline Materials

Design and characteristic analysis of giant magnetoimpedance sensor in Fe-based nanocrystalline ribbons

Resonant Magnetoelectric Coupling of Fe-Si-B/Pb(Zr,Ti)O3 Laminated Composites with Surface Crystalline Layers

Nonlinear Magnetoelectric Response of Fe73.5Cu1Nb3Si13.5B9/Piezofiber Composite for a Pulsed Magnetic Field Sensor

Characterization of magnetomechanical properties in FeGaB thin films

A Novel Spinel Ferrite-Hexagonal Ferrite Composite for Enhanced Magneto-Electric Coupling in a Bilayer with PZT

The Nonlinear ME Effect of FeNiMoSiB/ PZT-5A Composite under Step Magnetic Field Excitation for Magnetic Field Sensing

Magnetoelectric Effect in Shear-Mode Pb(Zr,Ti)O3/NdFeB Composite Cantilever

Large E-field Tunability of Microwave Ferromagnetic Properties in Fe59.3Co28.0Hf12.7/PZN-PT Multiferroic Composites

Large E-field Tunability of Microwave Ferromagnetic Properties in Fe50Co50-Hf/lead Zinc Niobate–lead Titanate Multiferroic Laminates

High-field dielectric properties and high-power performance of Fe-modified PZN–PMS–PZT piezoelectric ceramics

Correlation between dynamic magnetization process and dynamic domains of high saturation induction FeSiBNbCuMo nanocrystalline alloy with dual anisotropies

High-frequency magnetic characteristics and operating thermal stability of industrialized Fe76Si13B8Nb2Cu1 nanocrystalline alloy

A Flexible Multiferroic Composite with High Self-Biased Magnetoelectric Coupling

Converse Magnetoelectric Effect in Ni(Terfenol-D)/Pb(Zr,Ti)O-3 Bilayer-Laminated Composite

Near-zero magnetostriction in magnetostrictive FeCo alloys

High-performance vibration power generation using polycrystalline Fe–Co-based alloy due to large inverse magnetostrictive effect

Giant Magnetoelectric Effect of A Hybrid of Magnetostrictive and Piezoelectric Composites