Abstract:The effects of Ca(II), Mg(II), Cu(II), and Fe(III) on the flotation separation of spodumene from feldspar and quartz were investigated by single-mineral and artificial-mixed-ore flotation experiments using α-bromododecanoic acid (α-BDDA) as a collector. At pH≈7, Ca(II), Mg(II), and Cu(II) selectively improved the flotation of spodumene, which facilitated the separation of spodumene. Although Fe(III) exhibited strong activation ability, its selectivity toward spodumene was low, which impaired the separation of spodumene. Moreover, the sequence of addition of metal ions had an impact on the separation of spodumene. When Ca(II) and Mg(II) were used as activators in the artificial-mixed-ore flotation experiments, concentrates with recoveries of 75.6% and 76.3% and Li2O grades of 5.8% and 5.2% were obtained, respectively. Adsorption and activation mechanisms of metal ions were analyzed by adsorption amount measurements, Fourier transform infrared spectroscopy, species distribution calculation, and frontier orbital theory calculation. Results indicated that the amount of α-BDDA adsorbed on spodumene was higher than those adsorbed on feldspar and quartz when Ca(II), Mg(II), and Cu(II) were employed as activators, which led to a higher recovery of spodumene. When the pH was approximately 7, Ca(II), Mg(II), Fe(III), and Cu(II) were mainly present as Ca2+, Mg2+, Fe(OH)3 and Fe(OH)2+, and Cu(OH)2, Cu2+, and Cu(OH)+, respectively. The results of frontier orbital theory calculations demonstrated that α-BBBA, Ca2+, and Mg2+ easily adsorbed on spodumene than on feldspar and quartz. Therefore, Ca(II) and Mg(II) facilitated the separation of spodumene. However, Fe(OH)2+ preferentially reacted with spodumene, whereas Fe(OH)3 preferably reacted with feldspar and quartz, which caused low selectivity of Fe(III) toward spodumene. Similarly, Cu2+ and Cu(OH)+ easily adsorbed on spodumene, whereas Cu(OH)2 preferentially adsorbed on feldspar and quartz. Thus, the selectivity of Cu(II) toward spodumene was inferior compared to those of Ca(II) and Mg(II).

Effects of Several Ions on the Morphology of Iron Oxide Red Seeds Produced by Ammonium Process

Effect of ammonia on morphology, wettability and photoresponse of ZnO nanorods grown by hydrothermal method

Effects of Major Anions on Iron Release in Drinking Water Supply System

Effects of Alkyl Ether Amine and Calcium Ions on Fine Quartz Flotation and Its Guidance for Upgrading Vanadium from Stone Coal

Effect of Ferrous Ion on the Performance of an Anammox Reactor

Controlling Yield and Morphology for Gold Nanorods in a Seed-Mediated Synthesis Method for Cell Imaging

The Impacts of Common Ions on the Adsorption of Heavy Metal

Effects of metal ions on the flotation separation of spodumene from feldspar and quartz

Effect of impurity ions on the primary nucleation of ammonium alum precipitated from aqueous solution

Effect of dissolved unavoidable ions (Fe 3+ ) from iron-containing gangue minerals on dispersion behavior of zinc oxide ore

Short- and Long-Term Effects of Manganese, Zinc and Copper Ions on Nitrogen Removal in Nitritation-Anammox Process.

Comprehensive analysis of the impacts of iron-based nanoparticles and ions on Anammox process

The Effects of Coexisting Copper, Iron, Cobalt, Nickel, and Zinc Ions on Gold Recovery by Enhanced Cementation via Galvanic Interactions between Zero-Valent Aluminum and Activated Carbon in Ammonium Thiosulfate Systems

Effect of Common Ions in Agricultural Additives on the Retention of Cd, Cu, and Cr in Farmland Soils

Effect of Ion Migration of Multiple Copper-Zinc Alloy on the Crystal Structure of Calcium Carbonate Scale

Effects of brining on the corrosion of ZVI and its subsequent As(III/V) and Se(IV/VI) removal from water.

Effects of Several Metal Ions on Calli Induction and Seedling Differentiation of Cotton

Study on the Influence of Metal Ions on the Dispersion of Fine Calcium Gangue Minerals

The influence of metal ions on aqueous dispersions of graphite oxide

Comparative impacts of iron oxide nanoparticles and ferric ions on the growth of Citrus maxima

Ammonia-Induced Seed Layer Transformations in a Hydrothermal Growth Process of Zinc Oxide Nanowires