Abstract:Aimed at improving the treatment of wastewater leftover by sauce production, this paper studies the feasibility and treating effects of applying the membrane bioreactor to treating the sauce-production left-over wastewater. At the same time, the paper has also checked the impact of various parameters on the processing effects as well as the membrane fouling problem, such as dissolved oxygen, colority and so on. As is known, membrane bioreactor (MBR) is a new wastewater treatment technology, which has integrated membrane separation technology and biological treatment technology into one. The technology has been founding more and more uses in the chemical industry and the surrounding application areas, which has received more and more attention. It is concluded from the experiment that the system has a good quality in purifying the wastewater. When the inlet COD was 505 mg/L to 1 209 mg/L, the highest COD removal rate was 93%, and the lowest COD removal rate was 86%; MBR has also had nice turbidity removal efficiency, when the inlet turbidity was 251-471 NTU, the effluent turbidity would be less than 10 NTU, with the turbidity removal rate being as high as 98%. The MBR has also had good color removal efficiency. To be exact, when the inlet color was 180 to 200, the effluent color would be about 40, and the color removal rate was 79%. Furthermore, the membrane fouling process has also been studied with the mechanism of membrane fouling being analyzed. Our study results show that the membrane spout water flux would drop to half in an hour and then would be getting to slow down. Since the flux has an exponential relation with time, the total trans-membrane resistance would begin to increase slowly when it reaches a value at a bit faster speed. And membrane fouling of MBR develops slowly in the two mouths when the reactor runs properly.

The Temperature Influence on the Sauce Wastewater Treatment

Process Improvement to Prevent the Formation of Biogenic Amines During Soy Sauce Brewing.

Treatment of Wastewater by Sauce-Production with Membrane Bioreactor

Progress on Treatment Method for Wastewater from Soy Sauce Production

STUDY ON THE TREATMENT OF SAUCE WASTEWATER WITH ANAEROBIC BAFFLED REACTOR

Removal Effect of A/O Sbr Process for Soybean Wastewater

Experimental study on the decoloration of soy sauce wastewater by ABR

Efficacy and Mechanisms of Rotating Algal Biofilm System in Remediation of Soy Sauce Wastewater

Study on Treatment of Soybean Wastewater by Sequencing Batch Reactor

Sauce Wastewater Treatment Process Based on Synchronous Degradation of COD and Color

Study on Influencing Factors and Wechanism of the Decoloration of Sauce Wastewater

Effect Of Alkaline Pre-Treatment On Waste Activated Sludge Solubilization And Anaerobic Digestion

APPLICATION OF UASB OXIDATION DITCH PROCESS IN TREATMENT OF SAUCE WASTEWATER

STUDY ON TREATMENT OF SAUCE WASTEWATER BY HYDROLYTIC ACIDIFICATION-SBR-AIRFLOAT PROCESS

Chemical Oxygen Demand Removal in Na2so4 Saturated Wastewater by Cultivable Halotolerant Bacterial Community

Reuse of Coagulation Sludge: Removal of Color and COD from Soy Sauce Wastewater by Coagulation

Effect of SBR on soy milk wastewater treatment

Wet air oxidation treatment of H-acid wastewater

Using Yeast to Treat Soybean Wastewater and Realize Resource Recovery

EXPERIMENT ON TREATMENT OF BEAN-PROCESSING WASTEWATER BY ASBR PROCESS

Investigation to Experiment for Treatment of Organic Wastewater from Tomato Paste Processing by New Bioreactor