Wet air oxidation treatment of H-acid wastewater

Zhanpeng Jiang,Yong Liu,Zhihua Yang,Wanpeng Zhu,Yongyi Wang

IF: 6.9

1998-01-01

Journal of Environmental Sciences

Abstract:This paper presents the effect of reaction factors on wet air oxidation(WAO) of H-acid wastewater. Higher CODCr removal were observed at low initial pH, high reaction temperature and no addition of Na2SO4. Initial oxygen pressure PO2 should be consistent with the initial H-acid concentration. The changes of some indexes were also studied. A significant initial (about 10 min) rapid reduction in CODCr was observed at 200° and 250°C. The decline of pH and the increase of SO2- 4 concentration were found in all the experiments. Some formic acid and large amount of acetic acid were detected in the treated solution in this study. The analysis of off-gas indicated undetectable amount of SO2 and nitrogen oxides. The biodegradability of H-acid solution was greatly improved after WAO treatment. The ratio of BOD5/CODCr increased from initial 3.4% to 33.3% after one hour reaction at 160°3 and 3 MPa initial oxygen pressure (initial H-acid concentration: 10 g/L, mixing speed:300 r/min). The result of WAO of H-acid production wastewater was similar to that of WAO of H-acid pure compound in distilled water.