Abstract:Methyl carboxylate esters have been shown to be potent promoters of low-temperature methanol dehydration to dimethyl ether (DME) using various zeolite catalysts. In the present work, catalytic kinetic studies, in-situ Fourier-transform infrared spectroscopy (FT-IR) and solid-state nuclear magnetic resonance spectroscopy (NMR) techniques were used to elucidate the promotional mechanism of methyl carboxylate esters on methanol dehydration to DME, using the medium pore zeolite H-ZSM-5 (MFI) as the catalyst. Kinetic studies were performed using the very potent methyl n-hexanoate promoter. The DME yield was dependent on both the methanol and methyl n-hexanoate partial pressures across the temperature ranges used in this study (110 to 130 °C). This is consistent with the promoted reaction being a bimolecular reaction between methanol and ester species adsorbed at the catalyst active sites, via an SN2 type reaction, as previously postulated. The in-situ FT-IR studies reveal that the Brønsted acid (BA) sites on H-ZSM-5 were very rapidly titrated by ester carbonyl group adsorption and bonded more strongly with esters than with methanol. Upon methanol addition, an even lower DME formation temperature (30 °C) was observed with methyl n-hexanoate pretreated H-ZSM-5 samples in the in-situ NMR studies, further confirming the strong promotion of this methyl ester on methanol dehydration to DME. The adsorption and reactivity of different methyl esters on H-ZSM-5 indicates that while methyl formate more easily dissociates into a surface methoxy species, [Si(OMe)Al], and carboxylic acid, it is a less potent promoter than alkyl-chain-containing methyl esters in methanol dehydration to DME, which in turn did not show this dissociative behavior in the low-temperature NMR studies. This indicates that methyl alkyl carboxylates do not need to be dissociated to a surface methoxy species to promote the methanol dehydration reaction and that a bimolecular associative mechanism plays an important role in promoting DME formation.

Theoretical Studies on the Reaction Mechanisms of AlOOH- and Γ-Al2o3-catalysed Methanol Dehydration in the Gas and Liquid Phases

Reaction Kinetics of Methanol Dehydration over Combined AI203-HZSM-5 Solid Acids

Adsorption and Dehydration of Methanol on Al2o3 Catalyst

Study on the Methanol Dehydration in Slurry Reactor

Research on Si–Al Based Catalysts Prepared by Complete Liquid-Phase Method for DME Synthesis in a Slurry Reactor

Surface acidity and the dehydration of methanol to dimethyl ether

Kinetic Study of Complete Liquid-Phase Catalyst for Dimethyl Ether Synthesis

Microwave-assisted Catalytic Dehydration of Glycerol for Sustainable Production of Acrolein over a Microwave Absorbing Catalyst

Catalytic dehydration of methanol to dimethyl ether over micro–mesoporous ZSM-5/MCM-41 composite molecular sieves

Liquid-phase preparation of catalysts used in slurry reactors to synthesize dimethyl ether from syngas: Effect of heat-treatment atmosphere

Active sites and mechanism of aqueous phase methanol dehydrogenation on Pt/Al 2 O 3 catalysts from multiscale modeling, microkinetic modeling, and operando spectroscopy

Kinetic and Spectroscopic Studies of Methyl Ester Promoted Methanol Dehydration to Dimethyl Ether on ZSM-5 Zeolite

Multilevel quantum mechanical calculations show the role of promoter molecules in the dehydration of methanol to dimethyl ether in H-ZSM-5

Highly dispersed Ag2O-CuO nanospheres supported on γ-χ-Al2O3 for methanol dehydration to dimethyl ether

Liquid-Phase Preparation of Dme Slurry Catalysts Using Pseudo-Boehmite As Aluminum Source

Synthesis of Dimethyl Ether Via Methanol Dehydration over Combined Al2o3-Hzsm-5 Solid Acids

Stability of Zeolite HZSM-5 in Liquid Phase Dehydration of Methanol to Dimethyl Ether

A DRIFTS Study of Catalyzed Dehydration of Alcohols by Alumina-supported Heteropoly Acid

99/00320 Effect of oxide dispersion in a bifunctional catalyst on the formation of dimethyl ether

Dehydration of Methanol to Dimethyl Ether over Nb2O5 and NbOPO4 Catalysts: Microcalorimetric and FT-IR Studies

Unravelling Mechanistic Aspects of the Gas-Phase Ethanol Conversion: An Experimental and Computational Study on the Thermal Reactions of MO2 (+) (M=Mo, W) with Ethanol.