Abstract:Recently, there has been an increasing emphasis on the efficient utilization of energy resources. Precise control of gas injection can aid in achieving this objective. However, measuring the temperature and concentration of gases simultaneously presents a challenge. Therefore, it is essential to monitor and track irregular behavior, such as combustion processes, in real-time without interfering with the combustion flow. This study proposes a non-contact optical measurement method that does not disrupt the combustion flow. Direct absorption spectroscopy (DAS) is used to extract the absorption line during optical measurements. Since the choice of absorption line extraction method can affect temperature measurement results, the performance of linear and non-linear interpolation methods is compared. Temperature measurements of stable flames were compared using a thermocouple and the computed tomography-tunable diode laser absorption spectroscopy (CT-TDLAS) method. The relative temperature error at the center of the measurement area between the two measurement methods was found to be approximately 2%. To overcome the real-time temperature measurement limitation of thermocouples, the combustion process of premixed flames is measured using computed tomography (CT) technology. Additionally, to evaluate the real-time measurement superiority of CT-TDLAS, the combustion state is assessed by comparing the intensity of a single-camera image with simultaneous measurement using CT-TDLAS. The results demonstrate that the image intensity of the flame captured by a single camera and the temperature field measured by CT-TDLAS exhibit the same trends during the extinguishing process. Consequently, the superiority of CT-TDLAS measurement for temperature measurement is demonstrated, and the real-time measurement superiority is confirmed.

Temperature measurements of diesel fuel combustion with multicolor pyrometry

Research on Temperature Distribution of Combustion Flames Based on High Dynamic Range Imaging

Study of an Improved Two-Colour Method Integrated with the Emissivity Ratio Model and Its Application to Air- and Oxy-Fuel Flames in Industrial Furnaces

Temperature Distribution of Combustion Flame in the Gasoline Engine by Means of Two-Color Method

Refinement of the two-color pyrometry method for application in a direct injection diesel and natural gas compression-ignition engine

Theoretical Evaluation of Measurement Uncertainties of Two-Color Pyrometry Applied to Optical Diagnostics.

Particle surface temperature measurements with multicolor band pyrometry

Temperature measurements using multicolor pyrometry in thermal radiation heating environments.

Comparison of Measurement Techniques for Temperature and Soot Concentration in Premixed, Small-Scale Burner Flames

Measurement On The Surface Temperature Of Dispersed Chars In A Flat-Flame Burner Using Modified Rgb Pyrometry

Research on the Combustion Process of Ethanol Injected in the Intake Port Ignited by Diesel Fuel by Means of Two-color Method

A study on continuous temperature measurement using direct absorption spectroscopy for fuel-air premixed flames

Multiparameter Measurement in Ethylene Diffusion Flame Based on Time-Division Multiplexed Tunable Diode Laser Absorption Spectroscopy

Simultaneous In-Situ Measurement of Soot Volume Fraction, H2O Concentration, and Temperature in an Ethylene/Air Premixed Flame Using Tunable Diode Laser Absorption Spectroscopy

On-line Tracking of Pulverized Coal and Biomass Fuels Through Flame Spectrum Analysis

Measurement Performance of an Optical CCD-based Pyrometer System

Measurement of soot temperature, emissivity and concentration of a heavy-oil flame through pyrometric imaging

Application of Two-color Method in Combustion Diagnosis of IC Engine

Optical Diagnostics for Soot Measurement in the Cylinder of Diesel Engine

Surface temperature and emissivity measurement for materials exposed to a flame through two-color IR-thermography

Characterization of In-Cylinder Combustion Temperature Based on a Flame-Image Processing Technique