Abstract:By collecting the ripple current in the control coil, the self-sensing magnetic bearings can obtain rotor displacement information without a displacement sensor, which has the advantages of low cost and high integration. According to the problems of incomplete and inaccurate displacement information extraction caused by the traditional displacement estimation method using Fourier method to analyze the ripple current with non-stationary characteristics to estimate the rotor displacement with the Gibbs effect. Therefore, this paper proposes a rotor displacement estimation algorithm based on multiresolution filter bank biorthogonal spline wavelet for a magnetic bearing motor based on two-level switching power amplifier. This algorithm utilizes the biorthogonal spline wavelet with the characteristics of generalized linear phase and tight support, which can accurately demodulate the ripple current in the coil and extract the displacement information in the ripple current. Therefore, it is able to overcome the Gibbs effect in the traditional Fourier analysis estimation algorithm, to reduce the influence of ripple on rotor displacement estimation, and to improve the accuracy and stability of displacement estimation. In order to verify the correctness and effectiveness of the proposed algorithm, this paper establishes a simulation model of magnetic bearing in MATLAB Simulink and designs the proposed displacement estimator. Simulation results demonstrate that the proposed algorithm has higher accuracy and better stability than traditional displacement estimation algorithms. Experimental results show that the maximum deviation rate of the displacement estimation method proposed in this paper does not exceed 1% when the radial magnetic bearing gap is 0.5 mm, which can effectively estimate the rotor displacement.

Research on Self-Sensing Technique of Mover Displacement for Linear Oscillatory Motor with Two Separated Stators

High Efficiency Control Strategy for Linear Oscillatory Motor with Two Separated Stators

Design of linear oscillatory motor with two divided stators

Study on linear oscillatory motor with two divided stators and its control methods

Position Estimation Accuracy Improvement Based on Accurate Modeling of Self-Sensing Active Magnetic Bearings

Research on a moving-magnet linear oscillatory actuator with double stators and its application

Modeling and Analysis of a Novel Linear Oscillatory Motor With Two Divided Stators

Study on Self-Sensor of Linear Moving Magnet Compressor's Piston Stroke

Adaptive Full-Order Displacement Observer for Sensorless Resonant Frequency Tracking Control of Linear Oscillatory Machines

A Novel Two-Degree-of-freedom Spherical Ultrasonic Motor Using Three Travelling-Wave Type Annular Stators

Optimization research of stator with two degree-of-freedom traveling-wave spherical ultrasonic motor

Operating Characteristic Analysis of Linear Oscillatory Motor with Two Separated Stators

Novel Flux Reversal Linear Oscillatory Motor with Two Divided Stators

Two Degree of Freedom Spherical Ultrasonic Motor With Three Traveling-wave Stators

Research on dynamic characteristics simulation of moving-magnet double stators linear compressor

Resonant Frequency Tracking Control of Novel Moving-Magnet Type Linear Oscillatory Actuator

Displacement Estimation of Self-Sensing Magnetic Bearings Based on Biorthogonal Spline Wavelet

Trajectory control of a 2-DOF traveling wave type spherical ultrasonic motor

Modeling and Optimal Design of the Rotary-Linear Type Two-Degree-of-Freedom Ultrasonic Motors

Study on Force Characteristic of Moving Magnet-Iron Type Linear Oscillatory Actuator with Two Divided Stators

The Precise Modeling and Analysis of Demodulation Approach in Self-sensing Active Magnetic Bearings