Abstract:The characteristics of devolatilization, namely the release of volatile matter, of the coarse coal particles in the dense bed of a fluidized bed or circulating fluidized bed boiler plays an important role in coal particle ignition, burnt-out, bed temperature distribution and pollution formation. Though many studies have been conducted in this topic, the existing data were scatter and not sufficient for the boiler modelling and design.An experimentally study on the devolatilization of coarse coal particles was conducted in the dense bed of a fluidized bed reactor. Coal particles, held in a basket made with stainless steel mesh, were merged into the dense bed for a given time, and then pulled out from the bed and quickly quenched with liquid nitrogen. Provided volatile content was evenly distributed in the coal particles, the volatile matter loss in the dense. bed during the given period was obtained by subtracting the volatile content left in devolatilized coal particles from that of the raw coal particles. In the experiments, the temperature of bed materials was controlled at a desired value within 600-900 degrees C. Three different kinds of coals, belonging to lignite, bituminous, and lean coal respectively, were used. For each kind of the coal, three groups of coarse particles with different mean diameter between 2000 and 6000 mu m were tested. The time for devolatilization, was set as 10s, 30s, 60s, 120s and 180s respectively.Experimental results showed that the devolatilization of coarse coal particles in the dense bed can be divided into two stages: the first stage is fast release stage, and the other one is a slow release stage. Most of volatile matter is released during the fast release stage where pyrolysis happens shortly after coal particles were put into the dense bed. It was found that high bed temperature was in favour of volatile matter release. Though coal particle size is not sensitive to the total amount of volatile matter release, it appreciably affects the volatile matter release rate in the first stage. Meanwhile, the particle size effect is coupled with the coal type.

Attrition of Activated Carbon Particles in a Coupled Fluidized and Fixed Bed Reactor

CFD Simulation of an Agitated Gas-Fluidized Bed: Effects of Particle–particle Restitution Coefficient on the Hydrodynamics

Experimental and Numerical Study of Solids Concentration Distribution in Transition Section of Turbulent Fluidized Bed

Experimental and numerical investigation of solid behavior in a gas–solid turbulent fluidized bed

Stable Operating Range and Solids Residence Time of Fine Fluorite Particles in the Two-Stage Fluidized Bed

Heat Transfer of Batch Simulating Continuous Fluidized Bed with Wet Particles

Attrition Behavior of Fine Particles in a Fluidized Bed with Bimodal Particles: Influence of Particle Density and Size Ratio

Fluidized Bed Drying and Devolatilization of Lignite Washery Tailing Particles: Experiments and Modeling

Advanceson improving the attrition resistance of molecular sieve catalysts for fluidized bed

Analysis of HZSM‐5 molecular sieve particles attrition behavior under fluidized conditions

Particles attrition of binary mixtures in the coal-fueled chemical looping system based on fluidized bed

Effects of Interparticle Forces on Fluidization Characteristics in Liquid-Containing and High-Temperature Fluidized Beds

Influence of Temperature on Fluidized‐Bed Catalyst Attrition Behavior

Attrition of CaO-based adsorbent in a laboratory-scale fluidized system

An Experimental Study On The Devolatilization Of Coarse Coal Particles In A Fluidized Bed Combustor

Particle Residence Time and Pressure Drop in a Fluidized Bed with Internals

Tiny Structure of Fly Ash and Experiment of Dry Removing Carbon in Fluidization Bed

Filtered Model for the Cold-Model Gas–solid Flow in a Large-Scale MTO Fluidized Bed Reactor

Adsorption of volatile organic compounds on modified spherical activated carbon in a new cyclonic fluidized bed

Mass Equilibrium of Gas Desulfurization Bed Materials in a Circulating Fluidized Bed and the Variation of Chemical Composition

Study of the Bed Agglomeration in the Straw-Fired Fluidized Bed