Abstract:Polyoxymethylene dimethyl ethers (PODE)-ethanol compound combustion was conducted on a 4-cylinder turbocharged intercooling common-rail diesel engine, in which the ethanol homogeneous charge was ignited by the direct injection of PODE in the cylinder. The ethanol fuel was injected into the intake manifold of the engine at a certain energy fraction (0, 20, 30, 40 or 50%) of the fuel. This research is aimed to investigate the effects of premixed ethanol ratio on the compound combustion and exhaust pollutant emissions characteristics of the engine with a diesel oxidation catalyst (DOC). The results show that at low load, with the increment of ethanol ratio, the combustion phase of the compound combustion is postponed, the maximum combustion pressure decreases, the combustion duration increases firstly and then decreases, while the amount of premixed combustion and its peak heat release rate increase. At high load, premixed ethanol is prone to spontaneous combustion before PODE ignition. Both the maximum combustion pressure and the premixed heat release rate increase sharply. CA50 gets close to the top dead center (TDC), the combustion duration extends, and the ringing intensity increases with the increment of ethanol ratio, while the brake thermal efficiency is remarkably improved. Compound combustion simultaneously decreases the NOx and soot emissions, and changes the trade-off relation of NOx and soot at low load. But at high load, due to premixed ethanol spontaneous combustion, soot emission increases with the increment of ethanol ratio. The NO2, HC, CO, formaldehyde and acetaldehyde emissions of compound combustion are much higher compared to those of pure PODE combustion, and they all increase with the increment of ethanol ratio. Whereas, DOC can efficiently purify these increased emissions, even at low load, the catalytic efficiency of DOC is higher than 81.9%. After DOC, compound combustion does not cause excessive pollutant emissions.

Combustion and Emission Characteristics of Homogenous DME-Ethanol Spray Compression Ignition Combustion

Engine Performance and Emissions of A Compression Ignition Engine Operating on the Diesel-Methanol Blends

Combustion and Emission Characteristics of a DI Diesel Engine Fueled by Diesel-Methanol Blends

Study on injection characteristics of diesel and DME

Combustion and Emission Analysis of DME on Diesel Engine with Inline Pump

Combustion and Emission Characteristics of a DME (dimethyl Ether)-Diesel Dual Fuel Premixed Charge Compression Ignition Engine with EGR (exhaust Gas Recirculation)

Study on Combustion Characteristics of a DI Diesel Engine Operating on Diesel/Methanol Blends

An Investigation on Combustion and Exhaust Emissions of Direct Injection Diesel Engine Fuelled with Dimethyl Ether

Compound Combustion and Pollutant Emissions Characteristics of a Common-Rail Engine with Ethanol Homogeneous Charge and Polyoxymethylene Dimethyl Ethers Injection

Study of Combustion Characteristics of a Compression Ignition Engine Fuelled with Dimethyl Ether

Experimental Investigation on Injection and Combustion of Dimethyl Ether Fueled Diesel Engine

Effects of mixing ratio and injection timing on combustion and emissions of DME-ethanol engine

The Combustion Characteristics of Vehicular Turbocharged Dimethyl Ether Engine

Combustion Characteristics and Heat Release Analysis of A Compression Ignition Engine Operating on A Diesel/Methanol Blend

Study on the performance and emissions of a compression ignition engine fuelled with dimethyl ether

Combustion ,Performance and Emission Characteristics of Ethanol-fueled Engine with Diesel Micro-pilot Injection Ignition

Homogeneous charge combustion and emissions of ethanol ignited by pilot diesel on diesel engines

Combustion and Emission Characteristics of a Homogeneous Charge Compression Ignition Engine

Effect of the Addition of Ethanol on the Combustion and Emission Characteristics of a Common-Rail Dimethyl Ether Engine

Combustion and performance of heavy-duty diesel engines fuelled with dimethyl ether

Experimental study of effects of exhaust gas recirculation and combustion mode on combustion, emission, and performance of DME‐methanol ‐fueled turbocharged c ommon‐rail engine