Abstract:Mordenite and ZSM-5 seeds could grow on the surface of an asymmetric α-Al2O3 support using an identical organic-free aluminosilicate solution under the same hydrothermal conditions. It suggests that the phase of zeolite can be controlled by varying the type of seed. Continuous mordenite and ZSM-5 membranes were prepared by the secondary growth method using corresponding seeds under appropriate conditions. The water content in the secondary growth mixture strongly influenced the growth of zeolite crystals. ZSM-5 seeds grew at a smaller rate and showed a habit of thin hexagonal plate in a concentrated mixture, while the crystals with a habit of rectangular parallelepiped were formed from a diluted secondary growth mixture. ZSM-5 crystals had poor intergrowth in the former case, whereas the crystals were highly intergrown in the latter case. ZSM-5 crystals in either membrane have a random orientation. In contrast to ZSM-5 zeolite, the crystal orientation in the secondary grown mordenite membranes strongly depended on the water content in the secondary growth mixture. The crystals in the mordenite membrane developed in a diluted secondary growth mixture were oriented with the (150) face parallel to the support surface, whereas the crystals in the membrane grown in a concentrated mixture were oriented with the (002) face parallel to the support surface. These results suggest that the crystal orientation in mordenite membranes can be manipulated only by changing the water content in a secondary growth mixture. The formation of the preferred crystal orientation in the secondary grown mordenite membrane is discussed in terms of an “evolutionary selection” process.

PREPARATION OF B-Oriented MFI ZEOLITE FILMS BY MICROWAVE HEATING

Continuity Control of B-Oriented Mfi Zeolite Films by Microwave Synthesis

Enhanced Compactness of Oriented MFI Zeolite Films by Heat Treatment of Seed Layer

Dynamic Hydrothermal Synthesis of a B-Oriented MFI Zeolite Film

A Facile Fabrication of Highly B-Oriented Mfi Zeolite Films in the Teos-Tpaoh-H2o System Without Additives

Thermal processing of zeolite seed layers for the fabrication of compact oriented MFI zeolite films

Oriented Zeolite Mfi Monolayer Films on Metal Substrates by in Situ Crystallization

Insights into 1,2-Dihydroxybenzene Addition on Twin Suppression During the Secondary Hydrothermal Synthesis of B-Oriented MFI Zeolite Films

Solvent-Free Secondary Growth of Highly B-Oriented MFI Zeolite Films from Anhydrous Synthetic Powder.

Fabrication of B‐oriented MFI Zeolite Films under Neutral Conditions Without the Use of Hydrogen Fluoride

Rapid Synthesis of Mordenite Crystals by Microwave Heating

Synthesis of highly b-oriented zeolite MFI films by suppressing twin crystal growth during the secondary growth

High-Light-Transmittance and Low-Haze Antifog MFI Zeolite Films Fabricated by Solvothermal Secondary Growth

Single-Mode Microwave Heating-Induced Concurrent Out-of-Plane Twin Growth Suppression and In-Plane Epitaxial Growth Promotion of b-Oriented MFI Film under Mild Reaction Conditions

Rapid fabrication of highly b-oriented zeolite MFI thin films using ammonium salts as crystallization-mediating agents

Controlled Release of Siliceous Species for the Fabrication of Highly B-Oriented MFI Zeolite Films

Microwave Influence on Different M–O Bonds During MFI-Type Heteroatom (M) Zeolite Preparation

Synthesis of b-Oriented MFI-Type Zeolite Membrane on Porous Glass Support by in Situ Hydrothermal Crystallization

The control of phase and orientation in zeolite membranes by the secondary growth method

Microstructural Manipulation of MFI-type Zeolite Films/membranes: Current Status and Perspectives

Fabrication of B-Oriented MFI Zeolite Membranes by a Printing-Transfer Seed Layer Procedure.