Abstract:The occurrence of sulfur in coal direct liquefaction residue affects its further high quality and high value utilization. Electrochemical desulfurization is characterized by mild reaction conditions, simple operation, easy separation of sulfur conversion products and little influence on the properties of the liquefied residue. An anodic electrolytic oxidation desulphurization experiment was carried out on the liquefaction residue of the by-product of a coal-to-liquid enterprise in the slurry state. An electrochemical test and material characterization of raw materials before and after electrolysis showed that electrolytic oxidation can desulfurize the liquefaction residue under an alkaline condition. Linear sweep voltammetry (LSV) was used for the electrolysis experiments to obtain the optimal slurry concentration of 60 g/L. On this basis, the reaction kinetics were calculated, and the minimum activation energy in the interval at 0.9 (V vs. Hg/HgO) was 19.71 kJ/mol. The relationship between the electrolytic desulfurization of the liquefied residue and energy consumption was studied by the potentiostatic method. The influence of anodic potential and electrolytic temperature on the current density, cell voltage, desulfurization rate and energy consumption was investigated. The experimental results showed that the desulfurization rate and total energy consumption increase positively with the increase in reaction temperature and electrolytic potential in a certain range. The influence of the reaction temperature on the desulfurization rate and total energy consumption is more prominent than that of electrolytic potential, but the energy consumption of sulfur removal per unit mass does not show a positive correlation. Therefore, with the energy consumption per unit mass of sulfur removal as the efficiency index, the optimal experimental results were obtained: under the conditions of 0.8 (V vs. Hg/HgO) anode potential, 50 °C electrolytic temperature, 60 g/L slurry concentration and 14,400 s electrolytic time, the desulfurization rate was 18.85%, and the power consumption per unit mass of sulfur removal was 5585.74 W·s/g. The results of XPS, SEM, BET and IC showed that both inorganic and organic sulfur were removed by electrolytic oxidation, and the morphology, pore structure and chemical bond of the liquefied residue were affected by electrolytic oxidation. The research method provides a new idea and reference for the efficiency evaluation of desulfurization and hydrogen production from coal liquefaction residue.

Sulfide removal in coal liquefaction wastewater by gas stripping

Reconfiguration of Acid Gas Removal Process Matching the Integration of Coal Chemical Industry with Green Hydrogen

Two-stage Air Stripping Combined with Hydrolysis Acidification Process for Coal Gasification Wastewater Pretreatment.

Experimental Study on Electrochemical Desulfurization of Coal Liquefaction Residue

A New Process of Solveing Corrosion Problem of Refined Liquefied Gas

Removal of Hydrogen Sulfide in Cold Coal Gas by Anaerobic Bio-trickling Filter

Performance and Optimization of Integrated Biogas Bio-desulfurization Reactor

Treatment of Coal Gasification Wastewater by Biological Contact Oxidation-Anaerobic Hydrolysis Acidification-Anoxia-mbr

Research Progress of Removal of H2S from Coal Gas by Dry Method

Enhancing sulfate reduction and hydrogen sulfide removal through gas stripping in the acidogenesis phase of a two-phase anaerobic process

Ammonia removal from coal dry distillation wastewater

Removal of sulfur at high temperatures using iron-based sorbents supported on fine coal ash

Sulfide removal and water recovery from ethylene plant spent caustic by suspension crystallization and its optimization via response surface methodology

Simulation of H2S and CO2 Removal from IGCC Syngas by Cryogenic Distillation

Selective Removal of H2S over CO2 in a Membrane Gas–liquid Microdisperison Microreactor

Hydrogen sulfide removal from biogas in anaerobic fermentation by use of biological process

Neonatal enzymic development in the interpeduncular nucleus and surrounding ventral tegmentum

STUDY ON CO-GASIFICATION OF SLUDGE AND COAL IN SUPERCRITICAL WATER

Treatment of High Concentrated Ammonia-Nitrogen Wastewater in Coal Gasification Process by Air Stripping

Preparation and performance of multi-ionic composite coagulants based on coal gasification coarse slag by one-step acid leaching

On-site source-separation of microparticles and reuse of coal gasification wastewater via a micro-channel separator: Performance and separation mechanism