Abstract:The time-domain analysis on single-stage LLC power factor correction (PFC) converter is performed in this article, which reveals that PON mode may occur around the peak point of instantaneous input power and cause instability issue. In order avoid PON mode, the power boundary between PO and PON mode is calculated. For the common design methods of LLC PFC converter with average mode control strategy, the power boundary requires to be higher than the instantaneous input power at its worst point. However, higher power boundary brings higher rms value of resonant current, and causes higher reactive power loss. Therefore, it is a wasteful designing methodology, as the other points of instantaneous input power do not need such high power boundary. In order to improve the efficiency, a power boundary control strategy is proposed in this article. By controlling the input current to make the instantaneous input power follow the power boundary, PON mode is eliminated. Consequently, the required power boundary is overall reduced, and the minimal rms current of resonant tank can be achieved. Furthermore, the optimal parameter design is also presented. A 90240 VAC input and 250 W48 V output experimental prototype has been built to verify the analysis results.

Three-phase power factor correction based on one cycle bipolar control

A Digital Control Method for PFC Achieving High Power Factor

Study of a Single-stage Three-phase PFC DC/DC Converter With Series-parallel Connected Transforms

Three-phase Three-level PFC Rectifier Under Single-Cycle Control

Steady-State and Dynamic Study of One-Cycle-controlled Three-Phase Power-Factor Correction

The Research of Three Phase Voltage PWM Rectifier Based on Variable-Structure Control

Digital Controlled 400Hz Three-Phase Four-Wire PWM Rectifier with High Power Factor

Modeling and Controller Design of Active Power Factor Correction Based on L6562A

Three-phase Current-Source Buck Type PFC Converter with Reverse-Blocking IGBTs

Simulation on Three-phase PWM Inverter under One-cycle Control

Circuit Topology and Control of Three-Phase PFC Rectifier Bridge

A three-phase four-wire three-level active power filter based on one-cycle control

One-cycle Controller for Parallel-Connected Interleaving Critical Continous Conduction Mode PFC Converter

Study on the Three-Phase Four-Legs Active Filter Based on One-Cycle Control

High-Power-Factor Control Of Ipmsm Drive System With Small Dc-Link Capacitor

Three Phase PFC Converter with Multilevel Inductive Switching Network

A Primary Control Strategy for Boost-Flyback Single-Stage PFC Converter

Single-Stage Integrated Buck-Flyback PFC Converter With Low Total Harmonic Distortion Control

Power Boundary Controlled Single-Stage LLC Power Factor Correction Converter and Its Optimal Parameter Design

Design and implementation of active power factor correction controller IC

A Novel Current-Followed Single-Phase PFC Converter