Abstract:SummaryThis paper presented a modeling and control aspect with an offline‐based parameter optimization algorithm for effectively tuning the controller parameters of the three‐phase boost power factor correction (PFC) rectifier system. While analyzing the shortcomings of the traditional PI control with complex control transfer functions from small‐signal models and investigating the limitations of PI control on harmonic suppression from the internal model principle, a simplified form of control transfer functions based on the small‐signal model has been proposed with segmented control action. Consequently, the methodology has the advantages of both simplified control strategies and segmented PI‐repetitive control so as to achieve the performance of high‐power factor and to reduce total harmonic distortion in a broad range of load conditions. However, the segmented PI‐repetitive control contains many control parameters. Thus, the solution and optimization for tuning the controller parameters based on heuristic offline optimization technique have been used to speed up the design of control system parameters. The validity and feasibility of the proposed design and optimization are verified using a 5‐kW three‐phase PFC rectifier with digital signal processor (DSP) TMS320F28335 prototype hardware. The results were then compared with those of traditional controller designs, which show the improvements and effectiveness of rectifier performance after adopting the proposed design and optimization technique.

Three-phase Three-level PFC Rectifier Under Single-Cycle Control

Circuit Topology and Control of Three-Phase PFC Rectifier Bridge

A Novel Neutral Current Control Strategy for the Three-Phase Four-Wire Boost PFC Converter

A Digital Control Method for PFC Achieving High Power Factor

Study of a Single-stage Three-phase PFC DC/DC Converter With Series-parallel Connected Transforms

Digital Controlled 400Hz Three-Phase Four-Wire PWM Rectifier with High Power Factor

The Research of Three Phase Voltage PWM Rectifier Based on Variable-Structure Control

Simulation on Three-phase PWM Inverter under One-cycle Control

Direct Power Control with Constant Switching Frequency for Three-Level PWM Rectifier

Analysis and simulation study on single-phase H-bridge rectifier/inverter

Virtual Flux Based Direct Power Control for Three-Level PWM Rectifier

Direct Power Control Based on Natural Switching Surface for Three-Phase PWM Rectifiers

Design and Control Aspect of Segmented Proportional Integral-Repetitive Controller Parameter Optimization of the Three-Phase Boost Power Factor Correction Rectifier

Direct Power Control of Three-phase PWM Rectifier Based on DSP

TABLE-BASED Direct Power Control for Three-Level Neutral Point-Clamped Pulse-Width Modulated Rectifier

Design of Interleaved Boost PFC Converter with Peak Current Control

Steady-State and Dynamic Study of One-Cycle-controlled Three-Phase Power-Factor Correction

A ZCS AC/DC CONVERTER WITH HIGH POWER FACTOR BASED ON PWM CONTROL STRATEGY

Elimination of power control coupling in direct power control based on switching table for three-level PWM rectifier

Single Stage PFC Circuit with Full Bridge Structure

Three-phase power factor correction based on one cycle bipolar control