Abstract:Boiling crisis is the rapid formation of the quasi-continuous vapor film between the heater and the liquid when the heat supply exceeds a critical value. We propose a mechanism for the boiling crisis that is based on the spreading of the dry spot under a vapor bubble. The spreading is initiated by the vapor recoil force, a force coming from the liquid evaporation into the bubble. Since the evaporation intensity increases sharply near the triple contact line, the influence of the vapor recoil can be described as a change of the apparent contact angle. Therefore, for the most usual case of complete wetting of the heating surface by the liquid, the boiling crisis can be understood as a drying transition from complete to partial wetting. The state of nucleate boiling, which is boiling in its usual sense, is characterized by a very large rate of heat transfer from the heating surface to the bulk because the superheated liquid is carried away from the heating surface by the departing vapor bubbles. If the heating power is increased, the temperature of the heating surface increases with the heat flux. When the heat flux from the heater reaches a threshold value q CHF (the critical heat flux, CHF), the vapor bubbles suddenly form a film which covers the heating surface and insulates the latter from the bulk of the liquid. The temperature of the heating surface grows so rapidly that the heater can fuse unless its power is controlled. This phenomenon is known under the names of "boiling crisis," "burnout," or "Departure from Nucleate Boiling" (DNB) [1]. The final state of this transition is called film boiling. This problem has become very important since the 1940's, with the beginning of the industrial exploitation of heat exchangers with large heat fluxes (as with nuclear power stations). Since then a huge amount of research has been done for the various conditions of pool boiling (boiling without imposed external flow) and flow boiling (boiling of the flowing water) [2]. Numerous empirical correlations have been proposed, each describing the dependence of the CHF on the physical parameters of the liquid and of the heater more or less correctly for a particular geometry and particular conditions of boiling [2]. A strong dependence of the threshold on the details of the experimental setup coupled with difficulties in separating the consequences of DNB from its causes is at the origin of a large number of frequently controversial hypotheses [2]. The violence of boiling makes observations quite difficult. Good quality photographic experiments are presented in only a few articles (see e.g. [3] -- [6]). Despite an increasing interest in the physical aspect of the problem during recent years [7,8] and numerous empirical approaches, the underlying physics still remains obscure. In this Letter, we propose a model based on a non-equilibrium drying transition.

Experimental Study on Microscopic Evolving Process of Boiling Overheat Liquor in Boiler under Microcracking Condition

Experimental study on boiling mechanism of superheated liquid containing ethanol impurity under different leakage conditions

Study on mechanism and law of liquid overheating and explosive boiling caused by leakage

Experimental Observation of Jet Flow and Liquid Exploding Emission from Mini/Micro Tubes During Boiling

Experimental Research on the Two-Phase Explosive Boiling Mechanism of Superheated Liquid under Different Leakage Conditions

Influence of Thermal Stratification by Fire on Heat-Mass Coupling Response Mechanism of the Liquefied Tank

Mechanism Research Of Boiling Liquid Expanding Vapor Explosion

Experimental Research on the Explosion Boiling Mechanism of Superheated Liquids Containing Short Chain Alcohol Impurities with Different Boiling Points

Experimental Study on Explosive Boiling Mechanism of Superheated Liquid Containing Ethanol Impurities under Rapid Depressurization

Droplet Evaporation to Boiling in Van Der Waals Fluid

Experimental Observation On Bubble Dynamics During Nucleate Boiling In Micro/Mini/Macro Tubes

Two-Phase Expanding Mechanism And Pressure Response Characteristic Of Boiling Liquid Expanding Vapor Explosion Under Rapid Depressurization

Experimental study on boiling induced vibration excited by a single bubble

ICONE23-1761 AN EXPERIMENTAL STUDY ON BUBBLE BEHAVIORS IN FORCED CONVECTIVE SUBCOOLED BOILING OF HIGH SUBCOOLINGS

Visualized Investigation of the Onset of Flow Boiling Dynamic Instabilities in a Horizontal Arranged Tube under a High-Temperature Thermal Storage Boundary Condition

Scale Effect On Boiling Inception And Bubble Dynamics In Micro/Mini/Macro Tubes

Experimental investigation on the characteristics of bubble growth and slide on a downward-facing heater surface in flow boiling

Molecular dynamics simulation on liquid nanofilm boiling over vibrating surface

Experimental investigation on vibration characteristics of subcooled and saturated pool boiling

Microscale Boiling Heat Transfer in A Micro-Timescale at High Heat Fluxes

Boiling crisis and non-equilibrium drying transition