Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Experimental Research on the Explosion Boiling Mechanism of Superheated Liquids Containing Short Chain Alcohol Impurities with Different Boiling Points

Experimental Study on Explosive Boiling Mechanism of Superheated Liquid Containing Ethanol Impurities under Rapid Depressurization

Experimental study on boiling mechanism of superheated liquid containing ethanol impurity under different leakage conditions

Research on the Effect of Different Gas Release Conditions on the Explosive Boiling of Overheated Water Containing NaCl

Experimental Research on the Two-Phase Explosive Boiling Mechanism of Superheated Liquid under Different Leakage Conditions

Study on mechanism and law of liquid overheating and explosive boiling caused by leakage

Influence of Thermal Stratification by Fire on Heat-Mass Coupling Response Mechanism of the Liquefied Tank

Study of ethanol vapor explosion and prediction based on chemical kinetics under high temperature and pressure

Droplet Evaporation to Boiling in Van Der Waals Fluid

Mechanism Research Of Boiling Liquid Expanding Vapor Explosion

Interfacial Effects on Nucleate Boiling Heat Transfer of Binary Mixtures

Microexplosion Kinetics of Alcohol-Based Emulsified Biodiesel Droplets Evaporated in High Temperature

Effects of Component Proportions on Multi-Jet Instant Expansion of Binary Solutions under Flash Boiling Conditions

Heat Transfer and Pressure Drop of Vapor-Liquid Solid Three-Phase Boiling Flow of Binary Mixtures

Effect of Ethanol/n-Hexane Blending Ratio on Behaviors of Shock Waves in Flash-Boiling Jets

Evaporation and boiling of water-alcohol droplets: Dynamic characteristics of wetting and heat transfer

Experimental Study on Evaporation and Micro-Explosion Characteristics of Ethanol and Diesel Blended Droplets

Study on Marangoni Explosion of Binary Mixtures in a Liquid Layer

Two-Phase Expanding Mechanism And Pressure Response Characteristic Of Boiling Liquid Expanding Vapor Explosion Under Rapid Depressurization

Molecular dynamics study on the enhancement of heterogeneous nucleate boiling of mixed liquid on superhydrophilic surfaces

Quantitative Study on the Influence of Bubble Explosion on Evaporation Characteristics of Flash Boiling Spray Using UV-LAS Technique