Abstract:Sulfur-iodine thermochemical cycle is considered as a promising route for hydrogen production without CO2 emission. In this cycle, the hydrogen iodide conversion rate plays an important role in the total thermal efficiency to some extent. To improve the efficiency of HI decomposition, the homemade carbon membranes supported by a-alumina porous tubes were well-designed in a specific way and evaluated aiming at removing H-2 from HI decomposition reaction side. Permeability, selectivity and stability of self-designed carbon membranes are investigated in some gaseous components in the present work. Firstly, single-component (H-2/Ar) permeance was observed with differential pressure ranging from 0.05 to 0.2 Mpa. The result shows that differential pressure has little effect on H-2 and Ar permeance. Secondly, the hydrogen and argon permeance through carbon membrane is 3.1 x 10(-8) mol m(-2) s(-1) Pa-1 and 5.7 x 10(-10) mol m(-2) s(-1) Pa-1 respectively at 300 degrees C. The separation factor of H-2 and Ar is 54, which is greater than the theoretical value calculated by Knudsen diffusion equation. Thirdly, hydrogen permeability in the H-2-HI-H2O gaseous mixture system owns nearly the same as that of the single-component (H-2) at 300-500 degrees C. Due to the large molecule diameter, most of HI are stopped by carbon membrane. However, H2O molecules could pass through the carbon membrane obviously. The permselectivity of H-2/HI is over 310 at 500 degrees C. Last, after 10 h of stability tests, some slight damage are observed on the surface of carbon membrane according to the scanning electron micrograph (SEM). The structure change of carbon membrane gave rise to a little increase of H-2 permeance at 20-100 degrees C. (C) 2016 Hydrogen Energy Publications LLC. Published by Elsevier Ltd. All rights reserved.

EXPERIMENT AND SIMULATION STUDY ON HI DECOMPOSITION FOR SI THERMOCHEMICAL CYCLE

Detailed Kinetic Modeling of Homogeneous HI Decomposition for Hydrogen Production—part II: Effect of I2 on HI Decomposition

Detailed kinetic modeling and sensitivity analysis of hydrogen iodide decomposition in sulfur–iodine cycle for hydrogen production

Experimental Study on the Catalytic Decomposition of Hydrogen Iodide for SI Thermochemical Cycle

Thermodynamics and kinetics modeling for reactions and thermal efficiency evaluation of open-loop SI thermochemical cycle

Modeling sulfuric acid decomposition in a bayonet heat exchanger in the iodine-sulfur cycle for hydrogen production

Study of the Mechanism of the Catalytic Decomposition of Hydrogen Iodide (HI) over Carbon Materials for Hydrogen Production

The HI catalytic decomposition for the lab-scale H2 producing apparatus of the iodine-sulfur thermochemical cycle

INET's Catalysts Study for HI Decomposition in the Thermochemical Water-Splitting Iodine–sulfur Process for Hydrogen Production

Review of Thermodynamic Properties of the Components in HI Decomposition Section of the Iodine–sulfur Process

Experimental Study of the Characteristics of HI Distillation in the Thermochemical Iodine–Sulfur Cycle for Hydrogen Production

HI Decomposition over the HI-100 Test Apparatus at a Hydrogen Production Rate over 100 L/h

REVIEW OF SIMULATION METHODS OF THE DISTILLATION COLUMN AND THERMODYNAMIC MODELS IN THE HI DECOMPOSITION SECTION OF THE IODINE-SULFUR PROCESS

Process Design and Simulation of Open-Loop Sulfur-Iodine Thermo-Chemical Cycle for Hydrogen Production

Influence of the initial HI on the multiphase Bunsen reaction in the sulfur-iodine thermochemical cycle

Optimization design and stimulation of hydrogen production by sulfur-iodine thermo-chemical cycle process

Detailed Kinetic Modeling of Homogeneous H2SO4 Decomposition in the Sulfur–iodine Cycle for Hydrogen Production

Experimental investigation on two-phase separation\characteristics of Bunsen reaction in sulfur-iodine cycle for hydrogen production

Experimental and Numerical Investigation of Sulfuric Acid Decomposition for Hydrogen Production Via Iodine–sulfur Cycle

Carbon Membrane Performance on Hydrogen Separation in H2H2OHI Gaseous Mixture System in the Sulfur-Iodine Thermochemical Cycle

THERMODYNAMICS STUDY ON REACTIONS OF SULFUR IODINE THEMOCHEMICAL CYCLE FOR H2S-SPLITTING