Abstract:The Iodine Sulfur (IS) thermo-chemical process for the production of hydrogen is one of the most promising approaches for use of the high temperature process heat supplied by high temperature reactor, which was developed in the Institute of nuclear and new energy technology (INET) of Tsinghua University, China, and INET initiated the fundamental studies on IS cycle since 2005. Based on the experiment results obtained by fundamental researches, a lab-scaled closed cycle loop (IS-10), which featured in electro-electrodialysis (EED) for hydriodic acid (HI) concentration, was designed and built at INET. The loop was composed of three sections, i.e., Bunsen section, HI section and sulfuric acid section. The closed cycle experiment on the loop was successfully carried out recently. In HI section, HIx produced by Bunsen reaction was continuously purified through reverse Bunsen reaction, concentrated by EED, and then HI solution was obtained by distillation. Finally HI was catalytically decomposed to H-2 and I-2 with the conversion of 20%. In sulfuric acid section, sulfuric acid was continuously purified, concentrated by distillation, and catalytically decomposed to SO2, O-2 and H2O with the conversion of 75%. In Bunsen section, water, including recycled water, reacted with I-2 and SO2 recycled from HI section and sulfuric acid section to form two separated acids phases, thus to form a closed cycle. The closed cycle experiment lasted for 7 h with the hydrogen production rate of 10 NL/h, with Pt loaded on activated carbon and copper chromite used as the catalysts for HI and sulfuric acid decomposition, respectively. This paper summarizes the main features of IS-10 and the main results of the closed cycle experiment. So far IS-10 is the second reported facility on which closed experiment was carried out, and the first one with EED embedded to perform a closed cycle operation. (C) 2010 Professor T. Nejat Veziroglu. Published by Elsevier Ltd. All rights reserved.

Optimization design and stimulation of hydrogen production by sulfur-iodine thermo-chemical cycle process

Process Design and Simulation of Open-Loop Sulfur-Iodine Thermo-Chemical Cycle for Hydrogen Production

SIMULATION OF HYDROGEN PRODUCTION BY SULFUR-IODINE THERMO-CHEMICAL CYCLE PROCESS

Modeling and Validation of the Iodine‐sulfur Hydrogen Production Process

Experimental Study of the Characteristics of HI Distillation in the Thermochemical Iodine–Sulfur Cycle for Hydrogen Production

Thermal efficiency evaluation of the thermochemical H2S splitting cycle for the hydrogen and sulfur production

Design of Integrated Laboratory-Scale Iodine Sulfur Hydrogen Production Cycle at Inet

Comparison of Various Circuit Designs in the HI Decomposition Section of the Iodine–sulfur Process

MASS BALANCE ACHIEVED BY Aspen SOFTWARE FOR IODINE-SULFUR CYCLE

Comprehensive Comparative Analysis of Open-Loop and Closed-Loop Iodine-Sulfur Thermochemical Cycle for Hydrogen Production

Simultaneous Optimization Of Hydrogen Network With Desulfurization Processes Embedded

Analysis of Internal Heat Exchange Network and Hydrogen Production Efficiency of Iodine–sulfur Cycle for Nuclear Hydrogen Production

Simulation Study about the Effect of Pressure on Purification of H2SO4 and HIx Phases in the Iodine–sulfur Hydrogen Production Cycle

Experimental Study on the Purification of HIx Phase in the Iodine–sulfur Thermochemical Hydrogen Production Process

Study on a Lab-Scale Hydrogen Production by Closed Cycle Thermo-Chemical Iodine–sulfur Process

Hydrogen Production by Sulfur-Iodine Thermochemical Cycle — Current Status and Recent Advances

Review of Thermodynamic Properties of the Components in HI Decomposition Section of the Iodine–sulfur Process

Thermodynamics and kinetics modeling for reactions and thermal efficiency evaluation of open-loop SI thermochemical cycle

INET's Catalysts Study for HI Decomposition in the Thermochemical Water-Splitting Iodine–sulfur Process for Hydrogen Production

REVIEW OF SIMULATION METHODS OF THE DISTILLATION COLUMN AND THERMODYNAMIC MODELS IN THE HI DECOMPOSITION SECTION OF THE IODINE-SULFUR PROCESS

Experimental and Numerical Investigation of Sulfuric Acid Decomposition for Hydrogen Production Via Iodine–sulfur Cycle