Abstract:The cotton fire often occurs during storage, and it is valuable to reveal the combustion characteristics of cotton bales. However, most of the previous studies only focused on the combustion phenomenon of cotton bales after ignited externally. In fact, during the storage of cotton, the fire often originated from inside of a cotton bale, resulted from the sparks introduced into the cotton bale by the ginning machinery and the heat generated due to hygroscopic property. Therefore, an experimental study was conducted to investigate the effect of density on the smoldering characteristics of cotton bales ignited internally. In this study, the cotton densities of experimental study were 50, 60, 70, 80, 90, 100, 110 and 120 kg/m(3). The change rules of the smoldering spread rate in external horizontal, internal horizontal, and internal vertical during the combustion process as well as the mass loss of the cotton bales with these densities were studied, and the spreading processes of the smoldering in these cotton bales were also determined. The experimental results show that due to differences in the amount of oxygen and heat flux, an increase in density leads to a decrease in the spread rates in external horizontal, internal horizontal and internal vertical. With the increase in density, the porosity decreases and the amount of air is reduced, so the spread rate gradually decreases. However, the mass loss rate, i.e. the amount of burning cotton per unit time, increases with density. And, as the overall amount of cotton increases with density, the burning time also increases. (C) 2020 The Combustion Institute. Published by Elsevier Inc. All rights reserved.

Combustion Characteristics of Cotton Stalk in a Fluidized Bed

Experimental Study on Pyrolysis and Combustion Properties of Biomass Briquette.

Experimental Studies on Chopping Cotton Stalk when Compressed to High Densities

Technical Assessment of Bioenergy Recovery from Cotton Stalks Through Anaerobic Digestion Process and the Effects of Inexpensive Pre-Treatments

EXPERIMENTAL RESEARCH ON CORNCOB FAST PYROLYSIS FOR BIO-OIL IN A FLUIDIZED BED REACTOR

Combustion behaviours of tobacco stem in a thermogravimetric analyser and a pilot-scale fluidized bed reactor

Nonisothermal Thermogravimetric Kinetic Investigations On Combustion Behaviors Of Concomitant Biomass From Urban Plants

The exploration of pyrolysis characteristics, kinetics and products of cotton via TG, FTIR, GC/MS and shuffled complex evolution

Combustion characteristics of sludge in fluidized bed

Morphology, Composition, and Mixing State of Primary Particles from Combustion Sources — Crop Residue, Wood, and Solid Waste

Study on spontaneous combustion risk of cotton using a micro-calorimeter technique

Kinetic Analysis on Non-isothermal Combustion of Several Urban Biomass Fuels

Investigation on formation mechanisms of ash and deposit from cotton stalk vibrating grate boiler combustion based on their characteristics

Effect of Density on the Smoldering Characteristics of Cotton Bales Ignited Internally

Combustion characteristics of sewage sludge,coal water slurry and sludge-CWS mixtures by thermo gravimetric analysis

Spontaneous combustion identification of stored wet cotton using a C80 calorimeter

STUDY ON BIOMASS PYROLYSIS AND GASIFICATION IN A FLUIDIZED BED

Study on charicters and dynamics concerning pyrolysis of corn stalks

Study on the agglomeration in straw fired bubbling fluidized bed combustors

Low temperature carbonization and synergistic flame retardancy of cotton fabric coated by phosphorus‑nitrogen flame retardants

Research on Bed Agglomeration Formed During Fluidized Bed Combustion of Wheat Straw