Abstract:The microstructure, stress rupture properties and deformation mechanisms of a new alloy during long-term aging were investigated. The microstructure evolution mainly included the coarsening of gamma' phase and the precipitation of eta phase. During aging at 700 degrees C, 750 degrees C and 800 degrees C, the coarsening rate k of gamma' phase was about 7.818 nm(3)/h, 42.927 nm(3)/h and 178.226 nm(3)/h, respectively. The activation energy Q for gamma' coarsening was about 279.98 kJ/mol, which meant that element diffusion controlled the coarsening of gamma' phase. After aging at 750 degrees C for 3000 h and 800 degrees C for 2000 h, a new needle-like eta phase was precipitated near GBs and around MC carbides, then grew into the grain interiors. The quantity of eta phase increased with the increase of aging time. With the growth of eta phase, gamma' depleted zones were found around eta phase. This was principally because both gamma' phase and eta phase were enriched in Ni and Ti, and the growing up of I phase absorbed gamma' phase. After aging at 700 degrees C for 300-3000 h and 750 degrees C for 300-2000 h, the stress rupture life at 750 degrees C/430 MPa remained at a high level and most of them were higher than 100 h. That was because the slightly grown-up gamma' phase acted as strong obstacles to the dislocation motion, Orowan bypassing combing stacking fault shearing acted as the dominant mechanism during stress rupture deformation. After aging at 750 degrees C and 800 degrees C for 3000 h, the stress rupture life decreased to 45.7 h and 7.68 h, respectively. One reason was that the seriously grown-up gamma' phase was very hard to impede the dislocation motion, almost all gamma' phases were cut by dislocations with leaving stacking faults inside them during stress rupture deformation. The other reason was that needle-like eta phase promoted dislocation pile-up and contributed to the nucleation of micro-cracks, meanwhile the gamma' depleted zones could be conductive to the propagation of micro-cracks.

Growth kinetics of gamma ' phase of spray formed Ni-base superalloy during short-term ageing

Influence of Cooling Rate on the Formation of Bimodal Microstructures in Nickel-Base Superalloys During Continuous Two-Step Aging

Precipitation behavior of γ′ phase with a multi-model morphology in the Ni-based superalloy GH4720Li during water quenching and subsequent artificial aging and related mechanisms

Growth and dissolution behavior and morphology evolution of γ' precipitates in GH4742 nickel-based superalloy

Evolution of Lattice Spacing of Gamma Double Prime Precipitates During Aging of Polycrystalline Ni-Base Superalloys: an in Situ Investigation

The Precipitation Mechanism of the Secondary Phase in Inconel 617B Alloy During Ageing

The Effect of Coarsening of Γ′ Precipitate on Creep Properties of Ni-based Single Crystal Superalloys During Long-Term Aging

Effect of Long-Term Aging on the Microstructure, Stress Rupture Properties and Deformation Mechanisms of a New Cast Nickel Base Superalloy

On the early stages of precipitation during direct ageing of Alloy 718

Gamma Prime Precipitate Evolution During Aging of a Model Nickel-Based Superalloy

Morphological Evolution of Γ′ Precipitates in Superalloy M4706 During Thermal Aging

Precipitation behaviors of the rapidly-solidified Allvac 718Plus superalloy during aging treatment

Aging process design based on the morphological evolution of γ′ precipitates in a 4th generation nickel-based single crystal superalloy

Investigation of Precipitation Behavior of a Novel Ni-Fe-Based Superalloy during High-Temperature Aging Treatment

Coarsening Transitional Kinetics of Γ′ Precipitates in a Nickel-Based Single Crystal Superalloy During Thermal Exposure

Study of precipitation-assisted stress relaxation and creep behavior during the ageing of a nickel-iron superalloy

Coarsening kinetics of γ′ phase in isothermal aged high Al content Ni–17 at.% Al alloy

The Effect of Long-Term Aging on the Microstructure and Properties of a Novel Nickel-Based Powder Superalloy FGH4113A

Atomic-scale Investigation on the Mechanical Behaviors of the Γ′/γ′′ Co-Precipitates Compounds in Ni-based Superalloys

Hot deformation mechanisms of a new spray formed superalloy

Effect of Long-Term Aging on Microstructural Stability and Tensile Deformation of a Fe–Ni-based Superalloy