Abstract:Methanol is a very valuable chemical with a variety of uses, either as a fuel or as building block for the synthesis of other chemicals. In the last years, interest was growing in the production of methanol from CO2, based on the so called “Power-to-Fuel” concept. In this research, an equilibrium analysis of a methanol reactor with pure CO2 and H2 in the feeding stream was developed. Three novel reactor configurations at equilibrium conditions were considered: once-through reactor, reactor with recycle of unconverted gases after separation of methanol and water by condensation; reactor equipped with membrane permeable to water. An additional important feature of this work was the development of a methodology that assists in comparison of different process schemes by simulation of two different methanol plants configurations in ChemCad®. An adiabatic kinetic reactor with recycle of unconverted gases was considered and simulated in Aspen Plus®, while the performance of a methanol reactor with heat exchange at the pipe wall was simulated in MATLAB. Results show that at equilibrium conditions a reactor with the recycle of unconverted gases ensures the highest CO2 conversion: 69% at 473 K and 55 bar. In addition, the use of pure CO2 and H2 in the feeding stream allows an overall reaction enthalpy change lower than that obtained by the use of syngas in the feed. The kinetic simulation of the methanol reactor in MATLAB showed that axial dispersion phenomena are negligible and the effect of the global heat exchange coefficient on reactor performance is less important than the effect of isothermal heat exchange fluid temperature.

Mathematical Simulation of Methanol Synthesis in a Slurry Reactor

Simulation of Fluidized Bed Reactor for Methanol to Olefins(MTO)Process

Simulation of multi-fluidized-bed in series for methanol to olefins

THE MATHEMATICAL SIMULATION OF AN ETHOXYLATION TUBULAR REACTOR

Modeling and Simulation Research onm-Xylene Oxidation Reactor

Modeling and Simulation of Commercial Catalytic Reformers

Simulation, sensitivity analysis and optimization of a continuous catalytic reforming process

Simulation and Analysis of the Regeneration Process of Methanol to Propylene

Study on the Methanol Synthesis in Slurry Reactors

Numerical Simulation of CO Methanation for the Production of Synthetic Natural Gas in a Fluidized Bed Reactor

Numerical simulation of trickle bed reactors for biological methanation

Mathematical modeling of methane production and sulfate reduction in upflow anaerobic sludge blanket reactors: Calibration, validation and prediction of reciprocal effects

Thermodynamic simulation of methanol synthesis from biomass-derived syngas

Numerical Simulation of Mixing Capability in Coal-Slurry Mixing Tank

Methanol production by CO2 hydrogenation: Analysis and simulation of reactor performance

Kinetic Study of Complete Liquid-Phase Catalyst for Dimethyl Ether Synthesis

Three-Dimensional Simulation of the Methanation Process in a Circulating Fluidized-Bed Reactor

Modeling and Design of a Multi-Tubular Packed-Bed Reactor for Methanol Steam Reforming over a Cu/ZnO/Al2O3 Catalyst

Numerical Simulation of Thermal Performance for the Reaction Tubes in a Miniaturized Methanol Synthesis Reactor

Kinetic Model for High-Pressure Methanol Oxidation in Gas Phase and Supercritical Water

A Reduced Combustion Kinetic Model for the Methanol-Gasoline Blended Fuels on SI Engines