Abstract:For coal semi-char as a by-produced of low-temperature pyrolysis, combustion for power generation is one of the effective utilization methods to realize its clean and efficient utilization. However, the coal semi-char combustion process has a difficult ignition, unstable combustion and low burnout rate. The co-firing of the semi-char with biomass under oxy-fuel conditions can improve the combustion behavior and reduce fossil CO2 emissions. In this paper, the combustion behavior of Shenhua coal semi-char (SHC) co-firing with straw (ST) in O2/CO2 mixture is investigated using thermogravimetric analysis. The results show that each curve lays between those of the individual fuels and presents three peaks (i.e., three stages). The thermogravimetric curves of SHC co-firing with ST can be divided into three stages: the volatile combustion of ST, the co-combustion of SHC and ST fixed-carbons and the SHC fixed-carbon combustion and the decomposition of the difficult pyrolytic material of ST. Blending ST into the SHC can significantly decrease the ignition temperature and improve the comprehensive combustion behavior of blended samples. In increasing the proportion of ST from 25 to 100%, the change of the blended ignition temperature is slight, but the burnout temperature decreases greatly. Kinetic parameters of combustion are calculated by using the Coats–Redfern integral method. Compared to that of stage I and stage III, the activation energy of stage II is significantly lower. As increasing blending ratio from 25% to 100%, the activation energy increases at stage I and decreases at stage III. Furthermore, the O2 concentration obviously affects stage III of 50% SHC + 50% ST, and the thermogravimetric curves at this stage are obviously shifted to the lower temperature zone as the O2 concentration increases. The activation energy of 50% SHC + 50% ST increases as the oxygen concentration increases. Besides, the activation energy shows that the combustion characteristics cannot be determined only by the activation energy obtained by the Coats–Redfern method. These findings can provide useful information for semi-char co-firing with biomass.

Experiment Study on Combustion Performance of Oil Shale and Semi-coke Blends

Combustion kinetics study of oil shale semi-coke

STUDY ON COMBUSTION PROPERTY OF MIXTURE OF OIL SHALE AND HESHAN COAL

Study of the combustion mechanism of oil shale semicoke in a thermogravimetric analyzer

Catalytic Effects on Combustion Behavior of Oil Shale: Thermal Conversion, Kinetic, Mechanism Analyses

Investigation on the co-combustion of oil shale and municipal solid waste by using thermogravimetric analysis

Pyrolysis characteristics of oil shale semi-coke and its extracted bitumen

Low-temperature co-current oxidizing pyrolysis of oil shale: Study on the physicochemical properties, reactivity and exothermic characters of semi-coke as heat generation donor

Kinetic Study on Co-Combustion of Pulverized Anthracite and Bituminite for Blast Furnace Injection

Two-dimensional Combustion Modelling and Experimental Research on Oil Shale Semicoke

Non-isothermal Thermogravimetric Investigation on Mutual Effect Between Bituminite and Anthracite in Blends for Blast Furnace Injection

Experimental Study on Combustion Behaviors and Carbon Monoxide Emission Characteristics of Single Coal Pellets

Co-combustion of furfural residue waste and oil shale: characteristics, synergistic effects, kinetics, and optimization analysis

Kinetic study on the pyrolysis behavior of Huadian oil shale via non-isothermal thermogravimetric data

Experimental Study On The Comprehensive Behavior Of Combustion For Blended Coals

Investigation on co-combustion of semi-coke and bituminous coal in oxygen-enriched atmosphere: Combustion, thermal conversion, and kinetic analyses

Modeling Study of Combustion Process of Oil Shale Semicoke in a Circulating Fluidized Bed Boiler

Experimental investigation on ignition and burnout characteristics of semi-coke and bituminous coal blends

Thermogravimetric Analysis of Coal Semi-Char Co-Firing with Straw in O2/CO2 Mixtures

Experimental And Numerical Analyses On Ignition And Burnout Characteristic Of Low-Rank Lignite And Semi-Char Blends

Effect of final pyrolysis temperature on the composition and structure of shale oil: Synergistic use of multiple analysis and testing methods