Abstract:Atomistic simulations were used to elucidate the mechanisms of localized plasticity and fracture in Si nanofibers embedded in Al matrix, with uniaxial tensile straining along the fiber axis. The Si nanofibers within the Al matrix exhibited large non-linear elastic strains followed by localized plasticity with the latter accounting for approximately 5% permanent length increase in the fibers. On the other hand, simulations with aligned Si nanofibers in vacuum (no Al matrix) exhibited elastic deformation only followed by cleavage fracture. Localized plasticity in Si nanofibers is accomplished by gliding of "zonal" partial dislocations with Burgers vector b=aSi3〈112〉 , which leads to synchronous shear of two shuffle-sets. Local stress concentration in Si nanofibers due to non-screw segments of dislocation loops around fibers triggers yielding in the nanofibers through the activation of dislocation sources at or near the interfaces but only below some critical fiber diameter, highlighting the role of nanoscale refinement in activating plasticity in embedded Si nanofibers in Al matrix. In addition, the kinetic barriers associated with the glide of edge/screw zonal dislocation in the perfect crystal and twinned crystal are computed using climbing-image nudge elastic band method. A higher mobility of the zonal dislocation in the twinned crystal suggests that twin boundaries can assist in dislocation glide parallel to the boundary. On the other hand, a nano-crack is nucleated at the interaction position of a glide partial dislocation with an intersecting growth twin boundary suggesting that intersecting twins serve to block glide and provide sites for crack nucleation.

Residual Strain Around a Step Edge of Artificial Al∕Si(111)-7×7 Nanocluster

Steps of Al/Si nanocluster studied by scanning tunneling microscope Moire method

Steps of Al/Si Nanocluster Studied by Scanning Tunneling Microscope Moiré Method

Anisotropic Plastic Deformation Beneath Surface Step During Nanoindentation of FCC Al by Multiscale Analysis

Strain-induced structure transformations on Si(111) and Ge(111) surfaces: a combined density-functional and scannning tunnneling microscopy report

Anomalous Spiral Motion of Steps Near Dislocations on Silicon Surfaces

Lattice Bending, Disordering, and Amorphization Induced Plastic Deformation in a SiC Nanowire

Elastic Strain Relaxation of Phase Boundary of α′ Nanoscale Phase Mediated via the Point Defects Loop under Normal Strain

Strain Relaxation Induced by Interfacial Steps of GaAs/In0.2Ga0.8As Superlattices

Phase stability and the interface structure of a nanoscale Si crystallite in Al-based alloys

Different Strain Relief Behaviors in Al0.35ga0.65n/Gan Multiple Quantum Wells on Gan/Sapphire Templates with Aln/Gan Supperlattices and Low-Temperature Aln Interlayers

Analysis of Stress and Deformation States in Wedge Indented Face-Centered Cubic Single Crystals

High Strain Gradient Plasticity Associated with Wedge Indentation into Face-Centered Cubic Single Crystals: Geometrically Necessary Dislocation Densities

Defects Analysis of Al/Si Artificial Nanocluster with Moiré Fringes

Line Stress of Step Edges at Crystal Surfaces

Microscopic residual stress evolution at the SiC/Al interface during nanoindentation via molecular dynamics simulation

Effect of basal plane bending on the atomic step morphology of the 4H–SiC substrate surface

Arrays of widely spaced atomic steps on Si(111) mesas due to sublimation

Generation and distribution of residual stress during nano-grinding of monocrystalline silicon

Atomic Step Formation on Sapphire Surface in Ultra-precision Manufacturing

Atomistic Simulations of Dislocation Activity in Si Nanofibers in Al-Si Eutectics