Abstract:To get an optimized pulsed electrical plasma discharge reactor and to increase the energy utilization efficiency in the removal of pollutants, two hybrid plasma discharge reactors were designed and optimized. The reactors were compared via the discharge characteristics, energy transfer efficiency, the yields of the active species and the energy utilization in dye wastewater degradation. The results showed that under the same AC input power, the characteristics of the discharge waveform of the point-to-plate reactor were better. Under the same AC input power, the two reactors both had almost the same peak voltage of 22 kV. The peak current of the point-to-plate reactor was 146 A, while that of the wire-to-cylinder reactor was only 48.8 A. The peak powers of the point-to-plate reactor and the wire-to-cylinder reactor were 1.38 MW and 1.01 MW, respectively. The energy per pulse of the point-to-plate reactor was 0.2221 J, which was about 29.4% higher than that of the wire-to-cylinder reactor (0.1716 J). To remove 50% Acid Orange 7 (AO7), the energy utilizations of the point-to-plate reactor and the wire-to-cylinder reactor were 1.02 × 10−9 mol/L and 0.61 × 10−9 mol/L, respectively. In the point-to-plate reactor, the concentration of hydrogen peroxide in pure water was 3.6 mmol/L after 40 min of discharge, which was higher than that of the wire-to-cylinder reactor (2.5 mmol/L). The concentration of liquid phase ozone in the point-to-plate reactor (5.7 × 10−2 mmol/L) was about 26.7% higher than that in the wire-to-cylinder reactor (4.5 × 10−2 mmol/L). The analysis results of the variance showed that the type of reactor and reaction time had significant impacts on the yields of the hydrogen peroxide and ozone. The main degradation intermediates of AO7 identified by gas chromatography and mass spectrometry (GCMS) were acetic acid, maleic anhydride, p-benzoquinone, phenol, benzoic acid, phthalic anhydride, coumarin and 2-naphthol. Proposed degradation pathways were elucidated in light of the analyzed degradation products.

Decoloration of Acid Orange 7 Dye Aqueous Solution by a Multi-Needle-to-Plate High Voltage Pulsed Discharge Plasma System

Decoloration of Azo Dye by a Multi-Needle-to-plate High-Voltage Pulsed Corona Discharge System in Water

Degradation of Acid Orange 7 Dye in Two Hybrid Plasma Discharge Reactors

Degradation of Acid Orange 7 in an Atmospheric-Pressure Plasma-Solution System (gliding Discharge)

Evaluation of Energy Transfer and Utilization Efficiency of Azo Dye Removal by Different Pulsed Electrical Discharge Modes

Organic acids enhanced decoloration of azo dye in gas phase surface discharge plasma system

Effect of Persulfate on the Degradation of Acid Orange 7 (AO7) by Dielectric Barrier Discharge Plasma

Synergetic Degradation of Acid Orange 7 (AO7) Dye by DBD Plasma and Persulfate

Research on decoloration of dye wastewater by combination of pulsed discharge plasma and TiO2 nanoparticles

Kinetic and Physiochemical Effects of Decolorization of AO7 Dye Wastewater by DBD

Decolorization of Acid Orange 7 with DC Diaphragm Glow Discharge

Removal of Acid Orange 7 in simulated wastewater using a three-dimensional electrode reactor: removal mechanisms and dye degradation pathway.

Treatment of Dye Wastewater by Using a Hybrid Gas/Liquid Pulsed Discharge Plasma Reactor

Preparation of Carbon Micro- and Nanomaterials through Plasmochemical Treatment of Wastewater Contaminated with Acid Violet 7

Degradation of Azo Dye Acid Orange 7 by Uv-Activated Common Peroxides in Seawater System

Degradation of Acid Orange 7 Solution by Air-liquid Gliding Arc Discharge in Combination with TiO2 Catalyst

Degradation of Basic and Acid Dyes in High-Voltage Pulsed Discharge

Biodegradation Characteristics of Acid Orange 7 under Hypersaline Conditions.

Degradation of Acid Orange 7 in aqueous solution by a novel electro/Fe2+/peroxydisulfate process

[Decolorization and biodegradation of acid orange 7 by white-rot fungi]

Treatment of Saline Dye Wastewater Using Glow Discharge Plasma