Abstract:BACKGROUND: Phosphogypsum (PG) is a solid waste. For a fluidized bed, current research has focused on the preparation of CaO and SO2 by PG decomposition, while less research has been conducted with calcium sulfide (CaS) as the target product. Therefore, the effect of different conditions on the preparation of CaS by coal reduction of PG was investigated in a fluidized bed. The mechanism of the reaction between coal and PG was revealed through experiments and kinetic calculations. RESULTS: PG decomposition is a combination of solid-solid reaction (carbon reacting with CaSO4) and gas-solid reaction (reducing gas reacting with CaSO4), among which the solid-solid reaction plays a major role. A PG decomposition rate of 99.42% and CaS yield of 91.55% are obtained at 850 ?degrees C for 60 min when the Ca/C molar ratio is less than 0.25 and coal particle size is less than 0.075 mm. Lignite, bituminous coal and anthracite can promote the decomposition of PG. However, the higher viscosity of bituminous coal can lead to molten coking of the product, while anthracite is less economical, so lignite is the most suitable. Minerals in coal can improve the decomposition rate of PG. A fluidized bed improves the PG decomposition rate compared to a fixed bed. CONCLUSIONS: CaS is obtained by combined solid-solid and gas-solid reactions. Decreasing the Ca/C ratio and coal particle size as well as controlling the reaction temperature below 850 degrees C are beneficial for CaS generation. The minerals in coal can reduce the PG decomposition temperature and increase the PG decomposition rate. (C) 2022 Society of Chemical Industry (SCI).

Experiment on H2S removal by limestone in fluidized bed

Experiments on H2S sorption by limestone in a fluidized bed gasifier

Experimental Investigation on Sulfur Transformation During Coal Steam Gasification with Ca-based Absorbent

Experimental study of hot gas desulphurization with limestone sorbent

Experiment of H2S Evolution During Coal Pyrolysis in Fluidized Bed

Experimental Study of CaS Preparation from Lignite‐reduced Phosphogypsum in a Fluidized Bed

Hot Gas Desulfurization and Its Influence on Reverse Water Shift Reaction

Effects Of The Limestone Particle Size On The Sulfation Reactivity At Low So2 Concentrations Using A Lc-Tga

Effect of Reduction Atmosphere on Sulfur Dioxide Capture in CFB

Experimental Study on Combustion Desulfurization of Sludge Coal Water Slurry

Attrition of limestone during fluidized bed calcination and sulfation

Model on desulfurization characteristic of limestone particles

Experimental Study on the Treatment of Odor Gas Containing Hydrogen Sulfide by Immobilized Microorganisms

Effect of H_2S on the CO_2 capture capacity of limestone in calcination/carbonation cycles

Experimental Investigation of Limestone Dissolution Characteristics in a Micro-sized Bubbling Bed

Effects of high steam partial pressure on desulfurization process of limestone

Sulfur fate during bituminous coal combustion in an oxy-fired circulating fluidized bed combustor

Experimental Study on the Sulfation Characteristics of Limestone Under High CO2 Atmosphere

High-Temperature Sulfur Removal Under Fluidized-Bed Combustion Conditions - A Chemical Interpretation

Study on SO2 Emission under Various Atmospheres During Coal Combustion

Simulation of direct sulfation of limestone in oxy-fuel combustion