Abstract:Powder coatings are gaining popularity for their economic and environmental benefits. Additives (pigments) such as zinc phosphate enhance the anti-corrosive properties of coatings, but their behavior in powder coatings has not been extensively studied. In this study, zinc phosphate was incorporated into three powder coating systems: polyester clearcoat, polyester and epoxy coatings with filler BaSO4. Neutral salt spray and electrochemical tests (OCP, LPR, and EIS) confirmed that the anti-corrosive performance improved with the addition of zinc phosphate. The optimal additive dosage was determined to be 2% for all of the coating systems studied here, based on salt spray tests. Here, the time until failure increased by 1.5 to 2 times. Using electrochemical tests, an optimal additive dosage of 8% was found for the polyester clearcoat, while the other coating systems maintained an optimal additive dosage of 2%. Performance increased by as much as one order of magnitude based on resistance/impedance measurements. This suggested a synergistic effect between the additive and the filler. The passivation layer was confirmed by both X-ray diffraction and Raman spectroscopy. Based on the results and discussion presented in this article, the discrepancy was caused by different features of the two tests, such that the electrochemical tests probe the function of intact coatings, whereas salt spray measures only the corrosion spreading from the scribe. It is proposed that the two test methods characterize different aspects of the coatings, corresponding to their service conditions. This has theoretical and practical significance in the evaluation of anti-corrosive coatings. Other properties of the coatings, including adhesion, gloss, distinctness-of-image, and pencil hardness, were measured as per applicable standards and the conformance was verified.

STUDY OF THE ELECTROCHEMICAL BEHAVIORS OF THE ZINC-RICH PAINTS BASED MULTILAYER ORGANIC COATINGS IN NaCl SOLUTION

The Effect of Suspended Particles on the Corrosion Resistance of Electrodeposited Zinc Powders

Electrochemical Behavior of Organic and Inorganic Zinc-Rich Coatings in 3.5% NaCl Solution

Corrosion Study Of Zinc-Rich Epoxy Ester Paints For Cold Galvanizing Of Mild Steel

Influence of Zinc Content and Surface Contamination on the Electrochemical Behaviors of Epoxy Zinc-Rich Primer

Preparation and Corrosion Performance of Electrophoretic Epoxy Coatings Doped with ZrO2

Electrochemical impedance spectroscopy of multi-layer epoxy coatings in NaCl solution

Deterioration of Cathodic Protection Action of Zinc-Rich Paint Coatings in Atmospheric Exposure

Effect of iron powder on zinc reactivity and anticorrosion performance of zinc-rich epoxy coatings

Application of EIS and SECM Studies for Investigation of Anticorrosion Properties of Epoxy Coatings Containing Zinc Oxide Nanoparticles on Mild Steel in 3.5% NaCl Solution

A Comparative Study on the Anti-Corrosive Performance of Zinc Phosphate in Powder Coatings

EFFECT OF Mn ON CORROSION BEHAVIOR OF Zn IN A SIMULATED SOLUTION FOR MARINE ATMOSPHERE

Effect of chemical conversion induced by self-corrosion of zinc powders on enhancing corrosion protection performance of zinc-rich coatings

Influence of Surface Roughness on Performance of Zinc-Rich Paint Coatings

Corrosion protection of PPy-Ti3C2-modifed epoxy zinc-rich coatings in dilute NaCl solution

Corrosion protection performance of graphene-modified zinc-rich epoxy coatings under high-temperature and high-concentration NaCl solution

Degradation behavior of zinc-rich epoxy coatings in simulated marine tidal zone

Effect of Al Content on the Long-Term Corrosion Behavior of Arc-Sprayed ZnAl Alloy Coatings

Comparative Study of Carbonaceous and Polymer Conductive Additives on Anticorrosion Performance of Epoxy Zinc-Rich Primer

Study of the physical and electrochemical properties of hybrid paint system based on zinc-rich primer for mild steel protection

Potentiodynamical deposition and corrosion behavior of thin Zn-Sn coatings with layered structure and varied composition from deep eutectic solvent