Abstract:The early stages of polymer melt crystallization using fractionated isotactic polypropylene (iPP) as a model system were investigated via simultaneous synchrotron small-angle X-ray scattering (SAXS)/wide-angle X-ray diffraction (WAXD) and laser light scattering (LS) techniques. Since the crystallinity in the early stages is very low, the issue of the crystallinity detection limit of WAXD was addressed. This was done by using solutions of n-paraffin (C33H68) in dodecane (C12H26) at different concentrations las low as 1%). The precipitated fraction simulated the degree of crystallinity in polyethylene since n-paraffin essentially completely crystallized and dodecane remained liquid at the measurement temperature. A modeling method was also used to simulate the WAXD profiles to check the effect of crystal size at low crystallinity. With these two methods, we conclude that our WAXD procedure is capable of detecting crystallinity from 0.5% to 1%. During the early stages of iPP isothermal crystallization, noticeable short-range density fluctuations with average periods from 20 to 24 nm (by SAXS) were seen prior to the observation of three-dimensional ordering of the crystalline alpha-form (by WAXD). The spacing associated with the peak of the SAXS was found not to increase with time, being constant or a possible initial decrease, which is consistent with the formation of a finite lamellar structure. Furthermore, larger objects with dimensions growing from 300 nm were observed with the more sensitive technique of polarized light scattering, prior to the detection of the lamellar period by SAXS. The development of the crystallinity as measured by WAXD as well as SAXS and light scattering are all consistent, which follow the same Avrami equation, suggesting that the early stages of crystallization as measured here follow classical nucleation and growth.

A Novel Approach For Observing Morphology Of Polypropylene Under Ultrasonic Vibration By Sals

Effect of Superimposed Oscillatory Shear on Crystalline Behavior and Mechanical Properties of PE-LLD

Morphological Changes and SALS of Thermotropic Polyesters During Isotropic and Liquid Crystallization Transitions

Effect of Vibration on Crystal Morphology and Structure of Isotactic Polypropylene in Nonisothermal Crystallization

Crystallization and Mechanical Properties of Polypropylene Filled with Sio2 Nanoparticles

Deformation Mechanisms of Polymer Thin Films by Simultaneous Kinetic Measurement of Microscopic Infrared Dichroism and Macroscopic Stress. 2. Molecular Orientation During Necking Process of Isotactic Polypropylene

Vibration-Dependent Crystal Form of Isotactic Polypropylene under Nonisothermal Crystallization

Crystallization Measurements Via Ultrasonic Velocity: Study of Poly(Lactic Acid) Parts

Deformation Mechanisms of Polymer Thin Films by Simultaneous Kinetic Measurement of Microscopic Infrared Dichroism and Macroscopic Stress. Part Iii: Influence of Morphology on Molecular Orientation of Isotactic Polypropylene Films Subjected to Uniaxial Stretching

STUDY ON CRYSTALLIZATION BEHAVIOR OF ISOTACTIC POLYPROPYLENE PRODUCED BY SUPERCRITICAL POLYMERIZATION

Structure and morphology development in syndiotactic polypropylene during isothermal crystallization and subsequent melting

THE EFFECT OF MECHANICAL VIBRATION ON CRYSTALLIZATION OF POLYPROPYLENE

Probing the Early Stages of Melt Crystallization in Polypropylene by Simultaneous Small- and Wide-Angle X-ray Scattering and Laser Light Scattering

Synchrotron Investigation on Mesomorphic Structure of S PP and Poly(ethylene- Co -Octene) in Their Initial Crystallization Stage

Effects of Ultrasound on the Conformational and Crystallization Behavior of Isotactic Polypropylene Polymerized with Different Ziegler—Natta Catalyst

Low-Frequency Mechanical Spectroscopy Study Of Conformational Transition Of Polymer Chains In Concentrated Solutions

In-situ Investigation on the Structural Evolution of Mesomorphic Isotactic Polypropylene in a Continuous Heating Process

A Novel Apparatus Combining Polymer Extrusion Processing and X-Ray Scattering

Investigation on the Self-nucleation Behavior of Controlled-rheology Polypropylene

Isothermal crystallization kinetics of polypropylene/POSS composites

Experimental Study of Failure Mode Transition in Semi-Crystalline Polymers Polypropylene under High Strain Rate