Abstract:The formation of NO, NO 2 , N 2 O and N 2 from fuel-bound nitrogen species during the combustion of a coal slime (CS) and its char (CS char) were investigated in a laboratory bench-scale fluidised bed reactor by tracking the N-containing gas species using a gas chromatograph and an electrochemical gas analyser. Quartz sand with a particle size fraction of 0.3–0.38 mm was used as the bed material. A stream of an Ar/O 2 mixture of varying O 2 concentration was used as the oxidant and fluidisation gas. The effect of operating temperature (900–1300 K), initial O 2 concentration (3–8%), fuel feed rate (0.0041 g min −1 for CS, 0.0036 g min −1 for CS char) and C/O 2 mole ratio (0.14–0.78) on carbon burnout, NOx, N 2 O and N 2 formation were systematically studied. It was found that the oxidation process of CS in the fluidised bed is controlled by mass diffusion under the tested conditions. N 2 , N 2 O and NO concentrations in the flue gas during CS combustion were higher than during CS char combustion under the same experimental conditions due to the presence of the greater N content in CS (1.56%) than in CS char (1.34%). At low combustion temperatures of 900 K and 1000 K, the fuel-N was mainly converted to NO and N 2 O. However, as the operating temperature increased, NO and N 2 became the dominating species in both the CS and CS char combustion experiments. The NO concentration increased with increasing initial O 2 concentration due to enhanced oxidation of char-N. Comparing the N 2 formation data during CS and CS char combustion, it is inferred that in the presence of volatile, fuel-N was preferentially converted to N 2 .

Research on conversion of nitrogen in char during combustion under fluidized bed conditions

Experimental study on nitrous oxide formation during char combustion at fluidized bed conditions

Experimental investigations of the conversion of fuel-N, volatile-N and char-N to NOx and N 2 O during single coal particle fluidized bed combustion

Experimental and modeling investigation on char combustion and char-nitrogen evolution characteristics under different conditions

Char Nitrogen Conversion to NOx in a Fluidized Bed

A Thorough Theoretical Exploration of the Effect Mechanism of Fe on HCN Heterogeneous Formation from Nitrogen-Containing Char

Effect of Boundary Layer Reactions on the Conversion of CHAR-N to NO, N 2 O, and HCN at Fluidized-Bed Combustion Conditions

Experimental Study of Nitrogen Conversion During Char Combustion under a Pressurized O2/H2O Atmosphere

Effect of Reaction Conditions on Nitrogen Conversion During Char-O2/NO Combustion

Conversions of fuel-N to NO and N 2 O during devolatilization and char combustion stages of a single coal particle under oxy-fuel fluidized bed conditions

Experimental Investigation of Nitrous Oxide Formation During the Combustion of Coke in a Fluidized Bed

Conversions of fuel-N, volatile-N, and char-N to NO and N2O during combustion of a single coal particle in O2/N2 and O2/H2O at low temperature

Release of NOx Precursors During Coal Combustion

Influence of stoichiometry air ratio on char characteristics and nitrogen conversion in circulating fluidized bed with post-combustion

An experimental investigation into the fate of fuel-bound N-species during fluidised bed combustion of a dried coal slime in O 2 /Ar mixtures

Conversion of char-N into NOx and N2O during combustion of biomass char

An Experimental Research on the NO Release Characteristics of Low Volatile Coal

Conversion of Fuel-N to N2O and NOx During Coal Combustion in Combustors of Different Scale

Characteristics of NO release for the combustion of chars and volatiles of Anthracite

Experimental and kinetic study on the transformation of coal nitrogen in the preheating stage of preheating-combustion coupling process

The Characteristic of NO Release for the Chars and Volatiles of Bituminous During Combustion