Abstract:Solid concentration and particle velocity distributions in the transition section of a ϕ 200mm turbulent fluidized bed (TFB) and a ϕ 200mm annulus turbulent fluidized bed (A-TFB) with a ϕ 50mm central standpipe were measured using a PV6D optical probe. It is concluded that in turbulent regime, the axial distribution of solid concentration in A-TFB was similar to that in TFB, but the former had a shorter transition section. The axial solid concentration distribution, probability density, and power spectral distributions revealed that the standpipe hindered the turbulence of gas–solid two-phase flow at a low superficial gas velocity. Consequently, the bottom flow of A-TFB approached the bubbling fluidization pattern. By contrast, the standpipe facilitated the turbulence at a high superficial gas velocity, thus making the bottom flow of A-TFB approach the fast fluidization pattern. Both the particle velocity and solid concentration distribution presented a unimodal distribution in A-TFB and TFB. However, the standpipe at a high gas velocity and in the transition or dilute phase section significantly affected the radial distribution of flow parameters, presenting a bimodal distribution with particle concentration higher near the internal and external walls and in downward flow. Conversely, particle concentration in the middle annulus area was lower, and particles flowed upward. This result indicated that the standpipe destroyed the core-annular structure of TFB in the transition and dilute phase sections at a high gas velocity and also improved the particle distribution of TFB. In conclusion, the standpipe improved the fluidization quality and flow homogeneity at high gas velocity and in the transition or dilute phase section, but caused opposite phenomena at low gas velocity and in the dense-phase section.

Flow Behavior of Particles in an Annular Riser

Micro Flow Behaviors of Particles in Riser

Solid Concentration and Velocity Distributions in an Annulus Turbulent Fluidized Bed

MICRO FLOW BEHAVIOR OF PARTICLES IN DILUTE PHASE OF RISER

Investigation of Particle Flow Behaviors in a Simplified Downcomer of Multistage Fluidized Bed

Axial Velocity Distribution Of Particle Along The Radial Direction In Dilute Phase Of Riser

The Solid Flow Structure in A Circulating Fluidized Bed Riser/Downer of 0.42-M Diameter

Eulerian-Lagrangian Simulation of Distinct Clustering Phenomena and Rtds in Riser and Downer

Visualization Study On The Interface Of Core-Annulus Flow In A Circulating Fluidized Bed Riser By Piv

ANALYSIS OF FLOW STRUCTURE IN LARGE-SCALE CIRCULATING FLUIDIZED BEDS

Numerical Simulation of Fluid Dynamics of a Riser: Influence of Particle Rotation

Lateral solids dispersion in a high-density riser with swirling air flow

Flow Behavior of Clusters in a Riser Simulated by Direct Simulation Monte Carlo Method

Lateral Solids Mixing Behavior of Different Particles in A Riser with Fcc Particles As Fluidized Material

FLOW BEHAVIOR OF DENSE CLUSTERS IN RISER

Mixing behavior of wide-size-distribution particles in a FCC riser

Discrete element simulation of gas-solids flow behavior in riser

Experimental Study on Flow Patterns of Air-Water Two-Phase Flow in S-Shaped Flexible Riser

Solids Mixing Behavior in Riser with Internals

Axial and lateral dispersion of fine particles in a binary-solid riser

Hydrodynamics and Solids Mixing Behavior in A Riser with Blunt Internals