Abstract:Weakly-agglomerated nanocrystalline (ZrO2)(1-x)(Sc2O3)(x) ( x = 0.02 - 0.16) powders with high surface area (106 - 186 m(2) g(-1)) and uniform particle size (5.7 - 9.5 nm) were synthesized by a two-step hydrothermal process in the presence of urea, and their complex phase evolution upon calcinations over 400 - 1400 degreesC were studied by a combined utilization of X-ray diffraction, in situ high temperature X-ray diffraction, near infrared Fourier transform Raman and ultraviolet Raman spectroscopies. It was discovered that the growth of the grains comprised two stages, and the apparent activation energies, E-a1 (<800 degrees C) and E-a2 (>800 degreesC), are in the range of 5.5 - 12 kJ mol(-1) and 80 - 140 kJ mol(-1), respectively. The crystallite size, microstrain, surface area and growth activation energy of the samples showed a strong dependence on the Sc3+ doping concentration. The nanocrystalline (ZrO2)(1-x)(Sc2O3)(x) samples underwent complex phase transitions upon calcination from 800 to 1000 degreesC. Tetragonal and cubic phases have been preserved when the samples calcined below 800 degreesC as a result of crystallite size and doping effects. At elevated calcination temperature of 1000 degreesC, the compositions at x = 0.04, 0.10 and 0.14 seemed to be in the metastable phase boundaries of m + t, t + beta (Sc2Zr7O17) and beta+gamma (Sc2Zr5O13), respectively. As calcined at 1400 degreesC, the grain size was in the micrometre regime, and t --> m, c --> t", c --> beta and c --> gamma phase transitions occurred on the cooling stage for x less than or equal to 0.04, x = 0.08, 0.10 less than or equal to x less than or equal to 0.12 and x greater than or equal to 0.14, respectively, resulting in the existence of m, t, t", beta and gamma phases in turn at room temperature. Moreover, it was found that the tetragonal phase has been enriched at the surface region for the as-calcined (ZrO2)(0.94)(Sc2O3)(0.06) and (ZrO2)(0.92)(Sc2O3)(0.08) samples.

INFLUENCE OF SMALL AMOUNT OF DOPANT ON GRAIN SIZE AND PHASE COMPOSITION OF 8 % Mg- PARTIALLY STABILIZED ZIRCONIA

Effect of Magnesium Doping on the Light-Induced Hydrophilicity of Zno Thin Films

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

Effect of Ti Addition on the Microstructure and Mechanical Properties of Cast Mg-Gd-Y-Zn Alloys

Doping and Grain Size Effects in Nanocrystalline ZrO2–Sc2O3system with Complex Phase Transitions: XRD and Raman Studies

The Effect of Sm2o3-Dopant on the Microstructure and Dielectric Properties of Bazrxti1-Xo3 Ceramics

Effects of Doping Al2O3/2SiO2 on the Structure and Properties of Magnesium Matrix Ceramic

Effect of Y2O3 and ZnO co-doping on the densification and properties of magnesium aluminum spinel

Dopant behaviours of Sm2O3 on microstructure and properties of barium zirconium titanate ceramics

EFFECT OF DOPING CaO ON DIELECTRIC PROPERTIES OF BaZr0.05Ti0.95O3 CERAMICS

Effect of doping location induced anisotropy on thermophysical properties of dilute Fe 2 O 3 ‐Y 2 O 3 ‐ZrO 2 solid solutions

Effect of process parameters on microstructure and Raman characteristics of magnesium doped ZnO thin films

Co-precipitation of nano Mg–Y/ZrO2 ternary oxide eutectic system: Effects of calcination temperature

Sintering kinetics involving grain growth and densification of Mg-PSZ nanopowders

Influence of Y2O3 Doping on Phase Evolution and Dielectric Characteristics of ZrO2 Ceramics

Phase transition of nanostructure zirconias doped with rare earth elements.

Effects of MgO doping concentration on densification and microstructure of flash sintered α-Al2O3 ceramics

Effect of zirconium deficiency on structure characteristics, morphology and microwave dielectric properties of Li2Mg3Zr1-xO6 ceramics

On the Grain Size Distribution of MnO Doped ZnO Ceramics

Effect of MgO addition on properties of reaction-sintered ZrO2-toughened Al2O3 multiphase ceramic

Ball milling assisted preparation of nano La–Y/ZrO2 powder ternary oxide system: Influence of doping amounts