Abstract:The yield stress induced by external electric field generally of the order of kV mm(-1) is an important parameter for an electrorheological (ER) fluid. An ultrahigh yield stress of over 100 kPa of a general ER fluid in a slow compressive flow under an electric field of less than 0.6 kV mm(-1) has been achieved in this study, while its shear yield stress tested on a shear rheometer is only 0.6 kPa. A lower compressive velocity results in a higher yield stress under the same electric field. The large difference between the yield stresses is ascribed to the chain aggregation caused by the two-phase flow of liquid and particles during the slow compression. The viscous force acting on particles decreases as the compressive velocity increases, while the force acting from the neighboring particles to squeeze particles out increases. The increased particle-particle interaction established more interconnectivities among chain structures and greatly enhanced the yield strength of the ER fluid. The achieved result seems to deviate from the prediction of the Deborah number at a lower test velocity. The chain structure aggregation causing much longer relaxation times under slow compression has been employed to account for this deviation and the proper calculation of the Deborah number.

Transient Yield Characteristics Of Er Fluids Between Rotary Concentric Cylinders

Characteristics Of Electrorheological Fluid Flow Between Two Concentric Cylinders

A NUMERICAL SIMULATION OF TRANSIENT YIELD SURFACES OF ELECTRORHEOLOGICAL FLOWS IN CONCENTRIC CLUTCH

The Transient Behavior of Electrorheological Fluid in Tensile Flow

Transient Characteristics of the Yield Surface of Electrorheological Clutch

Ultrahigh Yield Stress in a General Electrorheological Fluid under Compression

Electrorheological Effects at High Shear Rate

Instability of Taylor-Couette Flow of Electrorheological Fluid

Compressions of Electrorheological Fluids under Different Initial Gap Distances

Electrorheological Fluid under Elongation, Compression, and Shearing.

Couette Flow of Electrorheological Fluids Between Two Concentric Cylinders with Wall Slip

Characteristics of Electrorheological Fluid Flow in Journal Bearings

MECHANICAL PROPERTIES OF ELECTRORHEOLOGICAL FLUIDS

The Giant Electrorheological Effect in Suspensions of Nanoparticles

Boundary Effect in Electrorheological Fluids.

Shear Thinning and Shear Thickening Characteristics in Electrorheological Fluids

Hydrodynamic Characteristics Of Er Fluid Flows In Journal Bearings

ELONGATION COMPRESSION AND SHEARING CHARACTERISTICS OF ER FLUIDS UNDER ELECTRIC FIELDS

Transient response of an electrorheological fluid under square-wave electric field excitation.

Reversible shear thickening at low shear rates of electrorheological fluids under electric fields

Tensile Behavior of Electrorheological Fluids under Direct Current Electric Fields