Abstract:Thermophilic anaerobic treatment of acidified and partially acidified wastewater was studied using Upflow Staged Sludge Bed (USSB) reactors. Reactors were composed of various compartments of which each was equipped with a gas-solid separator. This novel approach for thermophilic wastewater treatment led to a reduction or even elimination of major biological and physical limitations of conventional high rate thermophilic conversion processes. The main achievements of the plugflow reactor were i) very low concentrations of volatile fatty acids (VFA) in the effluent, ii) a high degree of sludge retention, and iii) stable reactor performance. The start-up of the reactors was done with either ‘crushed’ mesophilic granular sludge (MGS) or the digested organic fraction of municipal solid waste (OFMSW) as inoculum. A mixture of VFA and a mixture of sucrose-VFA were used as feed. A good operation performance was achieved within 1 month, and the granulation process of the thermophilic biomass was clearly visible after 1-1.5 months of operation. Within 2-3 months, the organic loading rate could be increased up to 100 kg sucrose-VFA-COD m−3 day−1 with a COD removal efficiency exceeding 90% at a HRT of 2-2.5 h. No significant wash-out of the thermophilic biomass was observed despite the extreme biogas load of 40-50 m3 m−3 reactor day. A certain percentage of sucrose was essential for the thermophilic granulation process; in the reactors treating solely the VFA mixture almost no granules were formed. Nevertheless, also in the latter reactors a satisfactory biomass hold up was observed despite the disperse nature of the sludge. The advantage of using compartmentalized reactors was clearly demonstrated under extreme loading conditions. A typical sequence in the degradation of the partially acidified substrate was found. In the first compartment sucrose was converted, followed by the conversion of butyrate and acetate in the next compartments. Propionate was the most difficult intermediate to degrade, but in the last compartments even this fatty acid was degraded almost completely.

Start-up of Full-Scale UASB Reactors

Municipal wastewater treatment by UASB process: start-up at 20 degrees C and operation at low temperatures

Performance of anammox UASB reactor treating low strength wastewater under moderate and low temperatures

A Case for Aerobic Sludge Granulation: from Pilot to Full Scale

Control Conditions of UASB Reactor for Concentrated Fruit Juice Wastewater

Hydrolysis and Methanogenesis in UASB-AnMBR Treating Municipal Wastewater Under Psychrophilic Conditions: Importance of Reactor Configuration and Inoculum

Characterization and Quantification of Anammox Start-Up in UASB Reactors Seeded with Conventional Activated Sludge

Start-up Strategies of UASB Reactor for Treatment of Pharmaceutical Wastewater.

Start-up Method of UASB for Landfill Leachate Treatment

A Study on the Performance Comparison between EGSB and UASB Reactors Treating Organic Wastewater

Start-up and Performance Evaluation of Upflow Anaerobic Sludge Blanket Reactor Treating Supernatant of Hydrothermally Treated Municipal Sludge: Effect of Initial Organic Loading Rate

Characterization of Granulation Process During UASB Start-up

High rate thermophilic anaerobic wastewater treatment in compartmentalized upflow reactors

Start-Up of Chitosan-Assisted Anaerobic Sludge Bed Reactors Treating Light Oxygenated Solvents under Intermittent Operation

STUDY ON TWO METHODS FOR STARTING UASB DURING THE TREATMENT OF CHLOROMYCETIN WASTEWATER

Performance of the UASB reactor during wastewater treatment and the effect of the biogas bubbles on its hydrodynamics

[Start-Up of a Thermophilic Anaerobic Sludge Digester].

High-efficiency Integrated UASB-MBR for High Concentration Organic Wastewater Treatment

Start-up strategy to achieve excellent efficiency of degradation acetate, ethanol and propionate in UASB

Long-term performance of UASB in treating N, N-dimethylformamide-containing wastewater with a rapid start-up by inoculating mixed sludge

BIODIESEL WASTEWATER TREATMENT BY UASB REACTOR WITH GRANULAR SLUDGE