Abstract:Anaerobic digestion is a promising waste-to-energy alternative technology. However, the efficiency upgrading for conventional mesophilic digestion of organic solid waste is always indispensable. Employing hyperthermophilic or thermophilic microbial community is one of the viable upgrading alternatives. Given the unavailability of the superior microbial communities, mesophilic digested sludge was used as inoculum, and instantly controlled at 70 °C and 55 °C for acclimation of hyperthermophilic and thermophilic inocula, respectively. Waste activated sludge was continuously and synchronously fed into two digesters. After one round, thermophilic digester achieved stable biogas production rate at 0.22 L L−1 d−1, with a methane proportion over 60%, whereas fluctuation was observed in the hyperthermophilic digester, and approximately triple time was needed to reach a relatively stable biogas production rate 0.12 L L−1 d−1. Nevertheless, higher hydrolysis ratio 24.4% was observed in the hyperthermophilic digester despite the lower biogas production. Therefore, methanogenesis step limited the whole anaerobic process for the hyperthermophilic digestion, and digestion at 70 °C was appropriate as a pre-fermentation stage to enhanced hydrolysis. The genus Methanothrix proportion in the thermophilic digester gradually decreased, while another acetoclastic genus Methanosarcina ultimately was acclimated to the dominant methanogen. In addition to Methanothrix, hydrogenotrophic archaea became competitive in the hyperthermophilic digester, with Methanothermobacter dominant at 22.6%. The genus Psychrobacter, affiliated to the phylum Proteobacteria could survive better than the others at 70 °C, with a final proportion of 62.5%.

[Start-Up of a Thermophilic Anaerobic Sludge Digester].

Examining A Hybrid Plug-Flow Pilot Reactor Foranaerobic Digestion of Farm-Based Biodegradable Solids

[Start-Up Research of Single Phase High Solid Anaerobic Digestion Technology for Organic Waste].

Pilot-scale Experiment on Thermally Hydrolyzed Sludge Liquor Anaerobic Digestion Using a Mesophilic Expanded Granular Sludge Bed Reactor

Start-up of High Solid Anaerobic Digestion Process for Treating Straw with Sludge Cake As Nitrogen Additive

One-step acquirement of superior microbial communities from mesophilic digested sludge to upgrade anaerobic digestion

Performance of Direct Anaerobic Digestion of Dewatered Sludge in Long-Term Operation

[Start-Up and Process Control of a Pilot-Scale Anammox Bioreactor at Ambient Temperature].

Characterization and Quantification of Anammox Start-Up in UASB Reactors Seeded with Conventional Activated Sludge

Study on the start-up operation and sludge characteristics of organic wastewater treated by the EGSB–two-stage anaerobic/aerobic biofilm process

Enhanced Anaerobic Treatment of Swine Wastewater with Exogenous Granular Sludge: Performance and Mechanism.

Internal Circulation Anaerobic Digester—a Upflow Anaerobic Sludge Digester

Fast Start-Up Strategies for Internal Circulation Anaerobic Reactor

Performance and Microbial Community Evaluation of Full-Scale Two-Phase Anaerobic Digestion of Waste Activated Sludge.

Optimizing Dry Anaerobic Digestion at Pilot Scale for Start-Up Strategy and Long-Term Operation: Organic Loading Rate, Temperature and Co-Digestion.

Start-up and Performance Evaluation of Upflow Anaerobic Sludge Blanket Reactor Treating Supernatant of Hydrothermally Treated Municipal Sludge: Effect of Initial Organic Loading Rate

Rapid Start-up Test of Semi-dry Thermophilic Anaerobic Digestion for Food Residue

Enhanced Anaerobic Digestion of Waste Activated Sludge of Low Organic Content in a Novel Digester.

[Pilot Study of Thermal Treatment/thermophilic Anaerobic Digestion Process Treating Waste Activated Sludge of High Solid Content].

Research on enhancing sewage sludge lysis and bioreactor initiation through composite thermophilic strains

Anaerobic Digestion of Oxidation Ditch Sludge at Low Temperatures with Hyperthermophilic Pretreatment