Abstract:The silicon-rich SiN(x) films were fabricated on Si(100) substrate and quartz substrate at different substrate temperatures varying from room temperature to 400 degrees C by bipolar pulse ane RF magnetron co-sputtering deposition technique. After deposition, the films were annealed in a nitrogen atmosphere by rapid photothermal annealing at 1050 degrees C for 3 minutes. This thermal step allows the formation of the silicon quantum dots. Fourier transform infrared spectroscopy, Raman spectroscopy, grazing incidence X-ray diffraction and photoluminescence spectroscopy were used to analyze the bonding configurations, microstructures and luminescence properties of the films. The experimental results showed that: silicon-rich Si-N bonds were found in Fourier transform infrared spectra, suggesting that the silicon-rich SiN, films were successfully prepared; when the substrate temperature was not lower than 200 degrees C, the Raman spectra of the films showed the transverse optical mode of Si-Si vibration, while the significant diffraction peaks of Si(111) and Si(311) were shown in grazing incidence X-ray diffraction spectra, confirming the formation of silicon quantum dots; our work indicated that there was an optimal substrate temperature (300 degrees C), which could significantly increase the amount and the crystalline volume fraction of silicon quantum dots; three visible photoluminescence bands can be obtained for both 30 degrees C sample and 400 degrees C sample, and in combination with Raman results, the emission peaks were reasonably explained by using the quantum confinement effect and radiative recombination defect state of Si nanocrystals; the average size of the silicon quantum dots is 3.5 and 3.4 nm for the 300 degrees C sample and 400 degrees C sample, respectively. These results are useful for optimizing the fabrication parameters of silicon quantum dots embedded in SiN. thin films and have valuable implications for silicon based photoelectric device applications.

Preparation and Characterization of InAs/Si Composite Film

Thermochemical process occurring in PLD-derived SiC films during vacuum annealing

STUDY OF PREPARATION AND PROPERTIES OF NANO-SCALE AgI- POROUS SiO2 COMPOSITES

Preparation of AIN Thin Film by DC Sputtering on SiO2/Si and Analysis of Microstructure

Preparation and Optical Properties of Inas0.4p0.6 Nanocrystal Alloy Embedded in Sio2 Thin Films

Structural And Optical Characterization Of Nanocrystals Of The Inas-Inp System Embedded In Amorphous Sio2 Thin Films

<title>Preparation of CoSi<formula><inf><roman>2</roman></inf></formula> using microwave hydrogen plasma annealing</title>

Oxidation Effects on InAs/GaSb (100) Films Deposited by DC Magnetron Sputtering During Post-Annealing

Effect of annealing on microstructure and photoluminescence of nano-composite silicon film

Preparation and Characteristic of FexSy/TiO2 Composite Material Film

Preparation of CoSi2 using microwave hydrogen plasma annealing

Influence of annealing on microstructures and photoluminescence of nano-composite silicon film

Preparation and Optical Properties of Composite Thin Films with Embedded InP Nanoparticles

Synthesis and thermal stability of SiC-Si3N4 composite ultrafine particles by laser-induced gas-phase reaction

Ellipsometric Study of the Optical Properties of Silicon-Based Si : Sio2 Composite Thin Films under Different Annealing Temperatures

Study on microstructure of Ag-SiO2 nanometer composite thin films

Precipitation and Crystallization of Nanometer Si Clusters in Annealed Si-Rich Sio2 Films

Characterization of ultrafine SiCSi3N4 composite powder after heat-treatment in Ar + N2

Preparation of CoSi2 Thin Film by Microwave Plasma Annealing

Fabrication and Characterization of Silicon Quantum Dots in Si-rich Silicon Carbide Films.

Spectral Characteristics of Si Quantum Dots Embedded in Sinx Thin Films Prepared by Magnetron Co-Sputtering