Abstract:Recent, studies have shown that selective flocculation flotation is an effective method for enhancing the flotation of a fine mineral. Fine-grained collophane is difficult to disperse naturally, thereby affecting its subsequent flotation separation. Therefore, it is important to study the dispersion behaviour and mechanism of fine-grained cellophane to choose an appropriate method to improve the dispersion effect of the flotation system. The influences of different types of poly-anionic dispersants, such as (sodium silicate (ZSS); sodium carbonate (ZSC); sodium hexametaphosphate, ZSP) and metallic cations with different valences (Al3+, Ca2+, Na+) on the dispersion behaviour effect of fine-grained collophane were investigated in this work using the sedimentation balance method. The zeta potential measurements and the extended-DLVO (Derain-Landau-Verwey-Overbake) theory were used to explain the distinction of dispersion behaviour. In the presence of dispersants, the dispersion of collophane was in the order of ZSP>ZSS>ZSC. Zeta potential analysis indicated that the absolute value of the surface potential followed the order of ZSP>ZSS>ZSC. That is, the collophane particles in the ZSP system had stronger electrostatic repulsion, resulting in a better dispersion zeta potential effect zeta potential. ZSP was adopted as dispersant to study the effects of metal ions on dispersion. In the ZSP dispersant system, metal ions can suppress the dispersion behaviour of fine-grained collophane. The suppression effect followed the order of Al3+>Ca2+>Na+, because of the greater charge and better neutralization ability of trivalent ions for the same concentration. The results of the extended-DLVO calculations showed that the dispersion stability was attributed to the electrostatic repulsion and hydration repulsion, and hydration repulsion had a greater influence on the stability than electrostatic repulsion. This paper provides reference information for adjusting the dispersion behaviour effect of fine-grained collophane, thereby guiding the actual flotation separation.

The role of dispersant in the formation of spherical ZrO2 particles prepared by heating of alcohol aqueous salt solutions

Research on dispersion characteristics of micron grade Al_2O_3 particle in water phase

Nano ZrO2 (Y2O3) Particles Processing by Heating of Ethanol–aqueous Salt Solutions

Investigation of the Process of Synthesizing ZrO2 Nanoparticles by Heating of Alcohol-Aqueous Salt Solutions

Influence of dispersant contents on rheological behavior of nano-sized tetragonal polycrystals zirconia's suspensions

Synthesis of yttria-stabilized zirconia nanoparticles by heating of alcohol-aqueous salt solutions

Deflocculation of Alumina Suspensions Using Polyelectrolyte Dispersants

Effect of dispersants on the physicochemical properties of ultra-fine ZrB2 powder in Sol-gel synthesis

Ethanol-Induced Aggregation of Nonpolar Nanoparticles in Water/Ethanol Mixed Solvents

Influence of Polyelectrolyte Dispersant on Slip Preparation of Nano-Sized Tetragonal Polycrystals Zirconia for Aqueous-Gel-tape-casting Process

An investigation on the properties of ZrO2 suspensions

Study on influence mechanism of surface active agent in preparing nano-sized zirconia powders by super-alkaline coprecipitation method

Dispersion and co-dispersion of ZrB2 and SiC nanopowders in ethanol

Influence of the Initial pH on the adsorption behaviour of dispersant on nano zirconia powder

Preparation of spherical ultrafine zirconia powder in microemulsion system and its dispersibility

Efficient Composite Dispersants for High Solid Content, Low Viscosity Nano-Zirconia Slurries: An Experimental and Molecular Dynamics Simulation Study

Influence of Water Soluble Polymer on ZnO Nanopowder by Chemical Liquid-Phase Method

Relation between ζ Potential and Dispersity in the Preparation Process of Nano-scale ZnO

Effects of Precipitators and Surfactants on the Preparation of Zirconia Nanopowders via Solvothermal Method

Dispersion behaviour of fine collophane particles in the presence of different dispersants and metal ions

Inter-particle interactions of alumina powders in UV-curable suspensions for DLP stereolithography and its effect on rheology, solid loading, and self-leveling behavior