Abstract:The modified Reynolds-averaged equation of motion for the turbulent fiber suspensions and the equation of probability distribution function for mean fiber orientation are derived. A successive iteration method is used for solving these equations. The method is applied to a turbulent pipe flow, and the probability distribution for mean fiber orientation, the streamwise mean velocity, the root mean square (rms) velocity fluctuations and the Reynolds stress are calculated. A satisfactory agreement between numerical and experimental results indicates that the method is reasonable and reliable, and can be methodologically applied to any incompressible turbulent flows of fiber suspensions. The results on the pipe flows show that most fibers orient along the flow. The rms radial velocity fluctuations are smaller than the rms streamwise velocity fluctuations. The maximum of rms velocity fluctuation appears in the near wall region. As the fiber mass concentration increases, the steepness of mean velocity profile increases, while the rms velocity fluctuation and the Reynolds stress decrease. The fibers suppress the turbulence and result in a reduction in Reynolds stress, and the effect of suppression and the amount of reduction are directly proportional to the fiber mass concentrations. The Reynolds number has less effect on the velocity profile. As the Reynolds number increases, the mean velocity profile becomes blunter, and the rms velocity fluctuations and the Reynolds stress increase. The effect of fiber aspect ratio on the mean velocity is more obvious than that of Reynolds number. As the fiber aspect ratio decreases, the mean velocity profile becomes blunter, and the rms velocity fluctuations and Reynolds stress decrease.

Simple variational criterion for turbulent flow in pipe

Predicting Mean Profiles in Compressible Turbulent Channel and Pipe Flows

Numerical simulation of 3-D turbulent flows in a cut-off valve and analysis of flow characteristics in pipe

Variational approach for resolving the flow of generalized Newtonian fluids in circular pipes and plane slits

EFFECTS OF VISCOSITY ON EQUATION OF MOTION AND CRITICAL FLOW VELOCITY OF FLUID-CONVEYING PIPE

A successive iteration method on predicting properties of turbulent fiber suspensions and its application to pipe flows

Variational approach for the flow of Ree-Eyring and Casson fluids in pipes

Numerical Analysis on Unsteady Intermittent Flow in a Rotating Curved Pipe

A mixed variational discretization for non-isothermal compressible flow in pipelines

Viscoelastic flow in rotating curved pipes

New equation of turbulent fibre suspensions and its solution and application to the pipe flow

Variational structure and two-dimensional subsonic jet flows for compressible Euler system with general incoming flows

Variational Structure and Two Dimensional Jet Flows for Compressible Euler System with Non-zero Vorticity

Vorticity evolution in a rigid pipe of circular cross-section

Critical Instability And Friction Scaling Of Fluid Flows Through Pipes With Rough Inner Surfaces

Stability of Stratified Gas-Liquid Flow in Horizontal and Near Horizontal Pipes

A unified friction factor formulation: Bridging laminar and turbulent friction factor with critical points analysis

Prediction of Mean Turbulent Flow Velocity in a Permeable-Walled Pipe

Prediction of the liquid film reversal of annular flow in vertical and inclined pipes

A Novel Variational Method for 3D Viscous Flow in Flow Channel of Turbomachines Based on Differential Geometry

A Short Remark on Stewart 1962 Variational Principle for Laminar Flow in a Uniform Duct