Abstract:An experimental simulation study on the transition from pressurized to boiling operation of a low-temperature, natural circulation nuclear heating reactor (5 MW) developed by INET of Tsinghua University is presented. The experiment was performed on the test loop (HRTL-5), which simulates the geometry and system design of the 5 MW reactor. The manifestation of different kinds of two-phase flow instabilities, namely geysering, flashing instability and low-steam quality density wave instability on the transition from pressurized to boiling operation is described. The mechanism of flashing instability, which has never been studied well on this field, is especially interpreted. It is suggested that the start-up process, from initial condition to boiling operation condition, should consist of three steps: (1) increasing of initial pressure by means of a noncondensable gas (N2), which is a very effective method to eliminate geysering and flashing instability at lower pressure. (2) start-up of the reactor at this pressurized condition with a constant heat flux under the limited value of 9 = 0.15 MW ?m-2, which controls the exit temperature of the heated section below the one of net vapor generation, the low steam quality density wave oscillation can be avoided. (3) transition to a lower pressure, boiling operation. The method of transition with low-heat flux and low-inlet subcooling is proposed: at pressurized operation condition, by reducing the heat flux to its lowest level, releasing the noncondensable gas and increasing the heat flux gradually (dq/dt3 kW ?m- 2 ?min-1l) , during which the low-steam quality density wave oscillation can be be prevented from occurring, then the boiling operation condition can be achieved through adjusting the heat flux and inlet subcooling to their designed value. A stable transition from pressurized to boiling operation of the 5 MW reactor is achieved by careful selection of the thermohydraulic parameters.

Experimental study on discharge character of non-condensed gas of NHR

Experimental investigation on the discharge fraction of non-condensed gas of nuclear heating reactor

THE EXPERIMENTAL INVESTIGATION OF STEAM CONDENSATION WITH NON-CONDENSABLE GAS UNDER NATURAL CONVECTION

Experimental Study of the Transient Characteristics of A Natural Circulation Loop under Sbloca

Experimental and Numerical Investigation of Sub-Cooled Boiling, Condensation, and Void Flashing in Nuclear Heating Reactor Test Loop

Analysis on Flow Characteristic of Nuclear Heating Reactor

Experimental Research on Steam Condensation in Presence of Non-Condensable Gas under High Pressure

Experimental simulation on transit process of the 5MW nuclear reactor

Conversion from Single to Two-Phase Operation in A Natural Circulation Nuclear Reactor

Experimental Study on the Condensation Characteristics of Nitrogen with Non-Condensable Gas

Numerical Simulation of Flow Distribution in the Lower Plenum of NHR200-II

Experimental simulation on LOCA of a nuclear heating reactor

Effect of Non-Condensation Gas on Heat Transfer of Direct Contact Condensation

THE EFFECTS OF A NON-CONDENSABLE GAS ON PRESSURIZER INSURGE TRANSIENTS UNDER THE HIGH PRESSURE

Simulation experiment study on LOCA at upper plenum of nuclear heating reactor

The Investigation on Heat Transfer Characteristics of Steam Condensation in Presence of Noncondensable Gas under Natural Convection

Study on dynamic character of thermohydraulic test system of 5MW low temperature nuclear heating reactor

Numerical Study Of The Gas-Steam Transient Behavior In The Integrated Pressurizer

Numerical Investigation of Natural Convective Condensation with Noncondensable Gases in the Reactor Containment after Severe Accidents

Two-dimensional Simulation and Experiments of Helium Discharge Between Parallel-Plate Electrodes in Short Gaps at Atmospheric Pressure

Experimental Investigation on Flow Behavior During Start-up of a Heating Reactor