Abstract:Considerable effort has been applied toward developing refractory high-entropy alloys (RHEAs) with both high strength and good ductility. However, the deformation and fatigue failure mechanisms of these alloys under cyclic loading remain poorly understood. The present work addresses this issue by investigating the low-cycle deformation behavior and microstructural evolution of an HfNbTiZr RHEA with a nominal composition of 25 mol% each of Hf, Nb, and Ti, and Zr forming the balance under symmetric tension-compression conditions at room temperature. Analysis of the cyclic stress responses of the alloy reveals a variety of internal stress trends at different strain amplitudes (Δεa), which implies the operations of a variety of cyclic deformation mechanisms. Further analysis demonstrates that cyclic softening is mainly caused by a rapid decrease in frictional stress during the initial cycles representing roughly 10% of the total number of cycles to failure. In general, the microstructural characteristics of the alloy observed with an increasing number of cycles under various values of Δεa demonstrate that softening occurs due to the formation of slip bands (SBs) caused by high-density dislocations arising in conjunction with increasing plastic strain accumulation. Specifically, dislocation structures forming at a low value of Δεa = 0.8% mainly consist of planar SBs (PSBs), while low-density cross SBs (CSBs) form at Δεa = 1.1%, and the density of the CSBs increases with further increasing Δεa. In addition, a fatigue lifetime prediction model was presented that obtained good prediction accuracy for the HfNbTiZr RHEA investigated herein. Accordingly, the present study can be expected to provide a fundamental basis for understanding the deformation mechanisms of other RHEAs.

Fatigue dislocation configurations in hexagonal Zircaloy-4

Deformation mechanism and cyclic stress response of Zircaloy-4 alloy cladding tube during low cycle fatigue at room temperature

Influence of Strain Amplitude on Low-Cycle Fatigue Behaviors of a Fourth-Generation Ni-Based Single-Crystal Superalloy at 980 °C

Fatigue-Induced HCP-to-FCC Phase Transformation Resulting in Two FCC-Zr Variants in Pure Zirconium

Micro-scale mechanism for cyclic deformation behavior in Zirconium under low-cycle-fatigue loading

Strain-Rate-Dependent Deformation Behavior of Ti29Zr24Nb23Hf24 High Entropy Alloys at Elevated and Room Temperature

In-situ EBSD analysis of hydride phase transformation and its effect on micromechanical behavior in Zircaloy-4 under uniaxial tensile loading

Hot deformation behaviour of Zircaloy-4 at varying strain rate and its microstructural evolution

Effects of deformation parameters and stress triaxiality on the fracture behaviors and microstructural evolution of an Al-Zn-Mg-Cu alloy

Deformation behavior and microstructure evolution of 7050 aluminum alloy during high temperature deformation

Fatigue Behaviors and Dislocation Evolution of Copper and Aluminum Alloy

Characterization of Hot Deformation Behavior and Processing Maps of Homogenized Al-Mg-Si-Sc-Zr Alloys

A Study of the Internal Deformation Fields and the Related Microstructure Evolution during Thermal Fatigue Tests of a Single-Crystal Ni-Base Superalloy

Characterisation of microstructural creep, strain rate and temperature sensitivity and computational crystal plasticity in Zircaloy-4

Fretting Fatigue Experiment and Polycrystal Plasticity Simulation in Ni-based Superalloy at Room Temperature and 650 °C

Low cycle fatigue properties of refractory high-entropy HfNbTiZr alloy

Damage Analysis of High Temperature Isothermal and Thermomechanical Fatigue on A Tzm Alloy

Deformation Behavior and Constitutive Model for Isothermal Compression of TC4 Alloy

On the Fatigue Short Crack Behaviors of Directionally Solidified Superalloy Dz4 by in Situ Sem Observations

Flow Behaviors and Dynamic Recrystallization Mechanisms Study of TC4 under Different Temperatures and Strain Rates

The Plastic Deformation Mechanisms of hcp Single Crystals with Different Orientations: Molecular Dynamics Simulations