Abstract:In the present work, a coating was prepared on an Al alloy substrate by plasma electrolytic oxidation (PEO). To seal the micro defects in the oxide scale, a siloxane layer was prepared on the PEO coating by sol gel method. The polymer sealant was synthesized from Tetraethoxy silane (TEOS) and methacryloxy propyl trimethoxyl silane (MPTES). The chemical structure of the polymer was studied by Fourier transform infrared spectroscopy (FTIR). The morphologies and microstructure of the PEO coating and siloxane coating were investigated by scanning electron microscopy (SEM). The results showed that siloxane formed a continuous layer on the surface and effectively sealed the micro defects. The corrosion behavior of the coatings in three different corrosion solutions (NaCl, HCl, and NaOH) was examined by electrochemical impedance spectroscopy and potentiodynamic polarization. The corrosion resistance of the sealed coatings was superior to that of the PEO coating because it prevented the penetration of corrosive solutions. The corrosion resistance of the sealed coatings was found to decrease with increasing electrolyte concentration. The work demonstrated that siloxane sealing may greatly enhance the corrosion resistance of Al-based PEO coating in acidic, neutral, and alkaline environments.

The Influences of Polyoxyethylene Ether on the Corroision Behaviors of Zinc and Zn-In Alloy in Alkaline Solutions

The Effect of Suspended Particles on the Corrosion Resistance of Electrodeposited Zinc Powders

Influences of zincate on corrosion electrochemical behavior of zinc in alkaline solutions

Influences of Zinc Oxide and an Organic Additive on the Electrochemical Behavior of Pure Aluminum in an Alkaline Solution

The effects of polyethylene glycol (PEG) as an electrolyte additive on the corrosion behavior and electrochemical performances of pure aluminum in an alkaline zincate solution

Composite Corrosion Inhibitors for Secondary Alkaline Zinc Anodes

The Corrosion and Electrochemical Behavior of Pure Aluminum in Additive‐containing Alkaline Methanol–water Mixed Solutions

Combined Corrosion Inhibitors for Secondary Alkaline Zinc Electrodes

Electrochemical Polarization and Corrosion Behavior of Al–Zn–In Based Alloy in Acidity and Alkalinity Solutions

Corrosion Behavior of ZnO-reinforced Coating on Aluminum Alloy Prepared by Plasma Electrolytic Oxidation

Electrodeposition and characterization of Zn–Sn alloy coatings from a deep eutectic solvent based on choline chloride for corrosion protection

Influence of Sealing Treatment on the Corrosion Resistance of PEO Coated Al-Zn-Mg-Cu Alloy in Various Environments

Influences Of Current Density On The Structure And Corrosion Resistance Of Ceramic Coatings On Zk60 Mg Alloy By Plasma Electrolytic Oxidation

Effects of Electrolyte Additives on Behavior of Al-In-Ga-Pb Alloy Anode

THE INHIBITION MECHANISM OF CYCLOHEXYLAMMONIUM TYPES OF INHIBITORS ON THECORROSION OF ZINC UNDER THIN ELECTROLYTE

Effect of electrolyte composition on corrosion behavior and tribological performance of plasma electrolytic oxidized TC4 alloy

Influence of polyethylene glycol inhibitors on properties of electroplated copper layer

Corrosion Behavior of Pure Zinc and Its Alloy under Thin Electrolyte Layer

Influences of trace indium and bismuth addition on corrosion behavior of zinc in alkaline solutions

The Cooperative Inhibition Effects of Alkaline Earth Metal Ions and Edta on the Corrosion of Pure Aluminum in an Alkaline Solution

Influence of Zn on Oxide Films on Alloy 690 in Borated and Lithiated High Temperature Water