Abstract:Zinc oxide (ZnO) films with thicknesses from (9.1 +/- 0.7) to (145 +/- 7) nm were deposited on silicon substrates by ion-assisted electron beam evaporation (EBE), and transformed to a highly (110)-oriented non-polar phase through thermal treatment at temperatures of 300, 500, and 700 degrees C. The structural, morphological and optical properties of the ZnO thin films were systematically characterized using transmission electron microscopy (TEM), X-ray diffraction (XRD), atomic force microscopy (AFM), spectroscopic ellipsometry (SE), and photoluminescence (PL). The XRD and AFM results illustrate that the deposited ZnO films evolved from an X-ray amorphous structure to the polycrystalline hexagonal wurtzite structure with increasing thickness and experienced a crystallographic plane improvement from (102) to the (110) non-polar phase during annealing. The dielectric functions of the whole layer are mainly affected by the dielectric responses near the surface of ZnO nanocrystals and show an upward trend with nanocrystal growth, induced by thickness and annealing temperature. The optical band gaps were also investigated and correlated with the structural properties. In the PL spectra, a strong ultraviolet luminescence (UVL) band and a weak visible green luminescence (GL) band were observed. The intensity ratio of UVL and GL-associated with crystal quality-agrees with the results acquired from other measurements. The two determinants for highly (110)-oriented non-polar ZnO films are the suppression of growth in the (002) direction by ion bombardment and the promotion of the (110) plane induced by diffusion energy during annealing. (C) 2017 Elsevier B.V. All rights reserved.

Fabrication and characterization of highly c -axial oriented ZnO films by chemical solution deposition

The growth of nanoscale ZnO films by pulsed-spray evaporation chemical vapor deposition and their structural, electric and optical properties

Effect of Nucleation and Growth Kinetics on the Electrical and Optical Properties of Undoped ZnO Films

The c-axis oriented ZnO thin films deposited by in situ sputtering at low temperature

Preferential growth of ZnO thin films by the atomic layer deposition technique

Structural, optical and electrical properties of ZnO thin films prepared by reactive deposition

Fabrication of Transparent ZnO Thick Film with Unusual Orientation by the Chemical Bath Deposition

Structural and Optical Properties of Highly (110)-Oriented Non-Polar ZnO Evaporated Films on Si Substrates

STRUCTURAL AND OPTICAL STUDIES OF ZnO FILMS GROWN AT LOW TEMPERATURE

Growth of C-Axis Orientation ZnO Films on Polymer Substrates by Radio-Frequency Magnetron Sputtering

Low-temperature Deposition of Transparent ZnO Films by the Ultrasonic-Mediated Stepwise Method

ZnO Films Synthesized by Solid-Source Chemical Vapor Deposition with c-Axis Parallel to Substrate

Preparation of ZAO film by low-temperature hydrothermal approach and its electrical property

Crystallization Properties of ZnO Thin Films Synthesized by Plasma Enhanced Chemical Vapor Deposition

Low Temperature Cathodic Electrodeposition of Nanocrystalline Zinc Oxide Thin Films

Preparation and Properties of High (002) Orientation ZnO-Li+ Films

Preparation of C-Axis Oriented ZnO Optical Waveguiding Films on Fused Silica by Pulsed Laser Reactive Ablation

Influence of fabrication technique on structure and optical properties of ZnO thin films

Deposition Condition Investigation of High c-axis Preferred Orientation ZnO Films Produced by RF Magnetron Sputtering

Effect of ZnCl2 assisted chemical bath deposition on preferred orientations and optical properties of ZnO films

Fabrication of Highly (1000) Oriented Textured Zinc Oxide Films by Metal Cathodic Arc and Oxygen Dual Plasma Deposition and Their Optical Properties